ページ1に含まれる内容の要旨
HANDS FREE CENTRAL FILTER
OPERATING INSTRUCTIONS
A. FILTER-DRAWER
WARNING!
WATER + HOT OIL = DON'T MIX!
1. Operator should be outfitted with proper protective
attire: safety goggles, oil and heat resistant gloves,
apron and footwear
FIGURE 1. QUICK DISCONNECT
2. Release intake hose from filter drawer using the quick
disconnect. Refer to Figure 1.
3. Pull filter drawer forward and remove the cover and
strainer basket. Refer to Figure 2.
4. Release the spring loaded T-Arms located in the corners
ページ2に含まれる内容の要旨
2. Remove screen from over tubes/element with tongs or a Drain Clean Out Rod. Refer to Figure 4. CAUTION Screen over tubes will be very hot and should be moved to a safe place. 3. Use spoon provided to stir oil. Bubbling will occur until all water is removed. Refer to Figure 5. NOTE: Water settles in the cooler oil in the Cold Zone. If the water is not removed, the filter paper absorbs the water preventing the oil from passing through it. FIGURE 4. REMOVE SCREEN OVER C. FILTRATION TUBES/ELEMENTS
ページ3に含まれる内容の要旨
D. CLEAN UP CAUTION: Filter drawer and pipes will remain hot following filtration. Allow the unit to cool down before clean up. Failure to do so may result in serious injury to the operator. 1. Release intake hose from filter drawer using the quick disconnect. Refer to Figure 10. 2. Pull filter drawer forward and remove the cover and strainer basket. Refer to Figure 2. 3. Release the spring loaded T-Arms located in the corners FIGURE 8. FILTER CONTROL PANEL of the filter drawer and remove the ho
ページ4に含まれる内容の要旨
CAUTION: A KEATING FRYER OR FILTER SHOULD BE DRAINED ONLY UNDER THE SUPERVISION OF PROPERLY TRAINED PERSONNEL. WHEN DISCARDING DISCARD OIL, A COVERED RECEPTACLE APPROVED FOR USE VALVE WITH HOT OIL SHOULD BE USED. USE OF A NON- HANDLE APPROVED RECEPTACLE OR METHOD OF DRAINING THE OIL COULD JEOPARDIZE THE SAFETY OF THE HOSE OPERATOR. CONNCETION (QUICK CLOSE DRAIN VALVE (REFER TO FIGURE 9) DISCONNECT) Fill fryer vessel to “Fill Level” line with water. Set thermostat and turn fryer on to bring water
ページ5に含まれる内容の要旨
PARTS LIST FOR CENTRAL FILTER DESCRIPTIONS PART NO. 1. Motor & Pump Assembly (not shown) 008196 (120V and 220V) 2. Strainer Basket CF14 014498 CF18 018316 CF20 018317 14 CF24 000454 13 3. Hold Down Ring CF14 013230 CF18 018016 CF20 018017 10 CF24 006711 11 4. Filter Paper CF14 052932 CF18 053850 17 CF20 053850 16 CF24 053851 17 5. Filter Screen CF14 005871 16 CF18,20,24 028787 6. “T” Handle CF14, 013132 CF18,20 010628 CF24 009196 7. Spring for “T” Handle 006656 8. Collar with Thumb Screw 029461
ページ6に含まれる内容の要旨
TROUBLESHOOTING GUIDE PROBLEM PROBABLE SOLUTION CAUSE Motor does not operate. 1. No electrical power to filter. 1. Verify electrical power is available to filter. 2. Motor overload tripped. 2. Turn filter switch to “OFF” then pull-on motor overload reset lever located in filter cabinet. 3. Open wiring. 3. If motor operates and then overload trips again, check for filter line blockage. If motor does not operate, check wiring for continuity. 4. Defective motor or switch. 4. Replace defective mot
ページ7に含まれる内容の要旨
WIRING DIAGRAMS KEATING OF CHICAGO, INC. Tel. 708-246-3000 Fax 708-246-3100 If you have any questions regarding filtering Toll Free 1-800-KEATING procedures or need assistance, call: www.keatingofchicago.com 1-800-KEATING. Central Filter pre2000 0107 9/07 – 7 –
ページ8に含まれる内容の要旨
WARRANTY LIMITED WARRANTY ® Keating Of Chicago, Inc. ("Keating”) warrants to the original purchaser. ("Customer"), all new Keating Fryers, Filter Systems, Griddles, Keep Krisp , Custom Pasta Systems, Top-Side™ Cookers, Computer Timers, Fryer & Pasta Vessels, and Keating replacement parts ("products") installed after June 1, 1994 to be free to defects in material or workmanship, subject to the following terms and conditions. LENGTH OF WARRANTY All products other than Fryer & Pasta Vessels and rep
ページ9に含まれる内容の要旨
SERVICE INFORMATION If you have a service related question call 1-800-KEATING. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. KEATING OF CHICAGO, INC. 8901 West 50th Street, McCook, Illinois 60525-6001 Phone: (708) 246-3000 FAX: (708) 246-3100 Toll Free 1-800-KEATING (In U.S. and Canada) www.keatingofchicago.com *As continuous product improvement occurs, specifications may be changed wit