ページ1に含まれる内容の要旨
Power Systems
GENERATOR USER MANUAL
S2800
MODEL & SERIAL NUMBER
Enter the Model and Serial numbers of your generator in the spaces provided below. Retain these numbers for
future reference. The Model and Serial numbers are located on the generator data plate on the alternator case or
generator frame, along with other important information. This manual contains important safety information. This
manual must be available to any personnel who operate or maintain this machine. Do not destroy.
Mode
ページ2に含まれる内容の要旨
CONTACT INFORMATION For Parts, Service or your nearest distributor call: U.S. and Canada (800) 445-1805 Latin America (305) 888-9911 Website: www.pramac.com English 0069439 2
ページ3に含まれる内容の要旨
Table of Contents ENGLISH INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ページ4に含まれる内容の要旨
SPANISH INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 SEGURIDAD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 informacion GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ページ5に含まれる内容の要旨
ENGLISH INSTRUCTIONS SAFETY ELECTROCUTION GENERAL INFORMATION DANGER: THIS GENERATOR SET PRODUCES This manual is provided so that your generator may be ELECTRICAL CURRENT. THEREFORE, SAFETY properly, safely and effectively applied and operated. Please GUIDELINES MUST BE FOLLOWED. IMPROPER USE read and understand all aspects of this manual before OF THIS GENERATOR CAN RESULT IN ELECTROCUTION, operating your generator set. Please also read and understand INJURY OR DEATH. DO NOT OPERATE, SERVICE
ページ6に含まれる内容の要旨
DANGER: DO NOT MODIFY OR MISAPPLY YOUR ENVIRONMENTAL PROTECTION GENERATOR SET. OPERATION OF THE GENERATOR OTHER THAN INTENDED COULD CAUTION: INSPECT THE EXHAUST SYSTEM RESULT IN GENERATOR SET DAMAGE, BODILY INJURY REGULARLY TO ENSURE IT IS FUNCTIONING OR EVEN DEATH FROM ELECTROCUTION. PROPERLY. LEAKY EXHAUST SYSTEMS WILL INCREASE NOISE LEVELS. DANGER: NEVER TOUCH A RECEPTACLE OR BARE WIRE. ELECTROCUTION OR SHOCK COULD RESULT. CAUTION: DIRECT THE “LOUD” SIDES OF THE FIRE GENERATOR INTO OPEN S
ページ7に含まれる内容の要旨
WARNING: REFER TO LOCAL AND NATIONAL ELECTRICAL CODES TO DETERMINE GROUNDING REQUIREMENTS AS THIS CAN VARY PER APPLICATION. THE GENERATOR IS GROUNDED INTERNALLY NEUTRAL TO FRAME. WHERE APPLICATIONS REQUIRE EXTERNAL GROUNDING, A CONNECTION MUST BE MADE FROM THE GENERATOR TO A SOLID EARTH GROUND. A CONTINUOUS LENGTH OF SPLICE-FREE COPPER CABLE, NO SMALLER THAN 6 AWG, SHALL BE USED FOR THE CONDUCTOR. • When moving or transporting this generator, take proper precautions to avoid fuel spillage.
ページ8に含まれる内容の要旨
LIMITED WARRANTY FOR PRAMAC POWER SYSTEMS PRODUCTS This warranty applies to generators, pressure washers, and water pumps commercialized by Pramac America, LLC in the USA and Canada. The warranty period begins from the date of purchase and is in effect for two (2) years or 1500 hours. Pramac will repair or replace, at its discretion, any parts determined to be defective under typical use by an authorized service provider or by Pramac. Pramac reserves the right to make the final decisions on all
ページ9に含まれる内容の要旨
OPERATION GENERAL INFORMATION This manual has been prepared to acquaint you with the operation and maintenance of this product. Study the information provided carefully to avoid problems associated with improper application or maintenance. Upon receipt of your generator, verify that it is complete and in good condition. The generator is comprised of a 4 stroke, air-cooled engine directly coupled to a 2 pole alternator producing either 125VAC or 125/250VAC depending on model. The no-load speed i
ページ10に含まれる内容の要旨
STARTING THE GENERATOR SET GENERAL WATTAGE GUIDE Item Running Watts Before attempting to start the generator set, ensure that all Air Conditioner (12000 Btu) (*) . . . . . . . . . . . . . . . . . . .1750 instructions given in previous sections have been followed Air Compressor (1/2 hp) (*) . . . . . . . . . . . . . . . . . . . . . .1400 completely. Air Compressor (3/4 hp) (*) . . . . . . . . . . . . . . . . . . . . . .1800 Air Compressor (1 hp) (*) . . . . . . . . . . . . . . . . . . . . . .
ページ11に含まれる内容の要旨
AS SHOWN IN THE TABLE BELOW. DO NOT EXCEED THE GENERATOR APPLICATION TOTAL GENERATOR NAMEPLATE RATING. All generator units are equipped with a thermal-magnetic main circuit WHAT IS A GENERATOR breaker as well as a "PUSH TO RESET" breaker on branch circuits. A generator is basically a prime mover, typically a gasoline or diesel engine, coupled to an alternator to produce electricity. It AMPERAGE RATE TABLE is very useful as a substitute power source during power outages or as the primary sourc
ページ12に含まれる内容の要旨
4. After the unit has cooled, drain gasoline from fuel tank, GENERAL STORAGE GUIDELINES fuel line and carburetor. 5. Pour about one teaspoon of engine oil through the spark WARNING: GASOLINE FUEL FUMES ARE plug hole, pull the recoil starter several times and replace FLAMMABLE. DO NOT STORE YOUR GENSET IN the plug. Then pull the starter until you feel the piston is ANY AREA THAT IS INDOOR OR IN POORLY on its compression stroke and leave it in that position. This VENTILATED AREAS. GASOLINE
ページ13に含まれる内容の要旨
OIL SELECTION Proper oil selection as well as proper oil level is critical to achieve maximum engine life. Use high detergent, premium quality motor oil certified for service class SJ that should be designated on the container. SAE 10W-30 is recommended for general, all temperature use. Use the table below to select the proper oil for the temperature in your area. Viscosity -30C/-22F -20C/-4F -10C/14F 0C/32F 10C/50F 20C/68F 30C/86F 40C/104F Single 10W 20W 20 30 40 Multi 20W-40, 20W-50 15W-40, 15
ページ14に含まれる内容の要旨
FAULT FINDING GUIDE SYMPTOMS PROBABLE CAUSES CORRECTION ENGINE WILL NOT START 1. Oil level too low. 1. Add oil. 2. No fuel or valve(s) turned off. 2. Add fuel and/or turn valve(s) on. 3. Start switch turned Off. 3. Turn switch On. 4. Blocked or leaking fuel system. 4. Repair fuel system. 5. Clogged air filter. 5. Clean or replace air filter. 6. Genset under load at start-up. 6. Disconnect load. NO POWER OUTPUT 1. Circuit breaker tripped. 1. Reset circuit breaker. 2. GFCI receptacle tripped. 2. R
ページ15に含まれる内容の要旨
PARTS ORDERING GENERAL The manual Insert, which contains an illustrated parts breakdown, has been prepared as an aid in locating those parts which may be required in the maintenance of the unit. All of the parts listed in the parts breakdown are manufactured with the same precision as the original equipment. For the greatest protection always insist on genuine Pramac America parts for your generator. NOTE: Pramac America, LLC can bear no responsibility for injury or damages resulting directly f
ページ16に含まれる内容の要旨
In the event parts are being returned to your nearest sales office, autonomous company or authorized distributor, for inspection or repair, it is important to include the serial number of the unit from which the parts were removed. TERMS AND CONDITIONS ON PARTS ORDERS Acceptance: Acceptance of an offer is expressly limited to the exact terms contained herein. If purchaser’s order form is used for acceptance of an offer, it is expressly understood and agreed that the terms and conditions of such
ページ17に含まれる内容の要旨
S2800 WIRING SCHEMATIC / SCHÉMA ÉLECTRIQUE D'INSTALLATION / ALAMBRADO ESQUEMATICO 0069439 17
ページ18に含まれる内容の要旨
S2800 PARTS DRAWING / SCHEMA DES PIÈCES / DIAGRAMA DE PIEZAS 0069439 18
ページ19に含まれる内容の要旨
S2800 PARTS LIST / LISTE DES PIÈCES / LISTA DE PIEZAS REF. PART DESCRIPTION DESCRIPTION DESCRIPCIÓN QTY NO. NO. 1 0069433 Handle, assembly Ensemble de Poignée Manija, conjunto 1 2 Note A Engine 169 cc Subaru OHC Moteur 169 cc Subaru Motor 169 cc Subaru 1 3 AMM2900RA0H1AZ Alternator Mecc Alte Alternateur Mecc Alte Alternador Mecc Alte 1 4 G052132 Isolator Sectionneur Aislador 2 5 0057254 Nut, hex flg 5/16-18 Écrous 5/16-18 Tuerca 5/16-18 2 6 0068679 Washer, flat 5/16
ページ20に含まれる内容の要旨
FRENCH INSTRUCTIONS SÉCURITÉ INFORMATION GENERALE PARE-ÉTINCELLES S’il doit être utilisé à proximité de matériaux inflammables Ce manuel est fourni pour que l'utilisation et l'opération de tels que récoltes, forêts, broussailles, herbes ou autres, il votre génératrice soient conformes sécuritaires et efficaces. est fortement recommandé d’installer un pare-étincelles, par S.V.P. lire attentivement tout le manuel et comprendre chacun ailleurs obligatoire en Californie. Les articles de la loi des
