ページ1に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ01
MODEL
R
ISSUE EMD-EU1728
2ZZ9020083
ページ2に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA1 WARNING: The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. NOTICE FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA EMISSION CONTROL WARRANTY are applicable to only those engines complied with EPA (Environmental Protection Agency) and CARB (California Air Resources Board) emission regulations in the U.S.A. NOTICE To the engines exported to
ページ3に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA2 FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE - This emission warranty is applic- able in all States, except the State of California Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein "ROBIN AMERICA") warrant(s) to the initial retail purchaser and each subsequent owner, that this Nonroad engine (herein "engine") has been designed, built, and equipped to conform at the time o
ページ4に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA3 *The replacement parts used for required maintenance services. *Consequential damages such as loss of time, inconvenience, loss of use of the engine or equip- ment, etc. *Diagnosis and inspection charges that do not result in warranty-eligible service being performed. *Any non-authorized replacement part, or malfunction of authorized parts due to use of non-autho- rized parts. OWNER'S WARRANTY RESPONSIBILITIES As the engine owner, you are resp
ページ5に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA4 CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Fuji Heavy Industries Ltd. (herein "FUJI") are pleased to explain the emission control system warranty on your 2001 and later Small Off-Road engine (herein "engine"). In California, the engine must be designed, built and equipped to meet the State's stringent anti-smog standards. FUJI must warrant the emission control syste
ページ6に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA5 LIMITED WARRANTY on Emission Control Systems - California Only - FUJI warrants to the owner of the 2001 and later engine that the engine (1)has been designed, built and equipped so as to conform at the time of manufacture with the applicable regulations of the California Air Resources Board, and (2) is free from defects in materials and workmanship that could cause it to fail to conform with those regulations as may be applicable in the terms a
ページ7に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA6 (4) repairs performed outside of the authorized warranty service dealers (5) use of parts which are not authorized by FUJI. 2. Add-on or modified parts This warranty does not cover any part that malfunctions, fails or is damaged due to alter- ations by changing, adding to or removing parts from the engine. 3. Expenses incurred by processing warranty claims FUJI, any authorized service dealer and warranty station shall not be liable for any loss
ページ8に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページA7 (5) Miscellaneous Items Used in Above Systems (i)Electronic controls, if applicable (ii)Hoses, belts, connectors, and assemblies. (iii) Filter lock assy (gaseous fuel, if applicable) I. MAINTENANCE STATEMENTS It is your responsibility to have all scheduled inspection and maintenance services performed at the times recommended in the 2001 and later Owner's Manual and to retain proof that inspection and maintenance services are performed at the t
ページ9に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ0-1 FOREWORD Thank you very much for purchasing a ROBIN ENGINE. Your ROBIN ENGINE can supply the power to operate various sorts of machines and equipment. Please take a moment to familiarize yourself with the proper operation and maintenance procedures in order to maximize the safe and efficient use of this product. Due to constant efforts to improve our products, certain proce- dures and specifications are subjected to change without notice. When
ページ10に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ0-2 CONTENTS 1.SAFETY PRECAUTIONS ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ 1 2. COMPONENTS ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ 4 3. PRE-OPERATION CHECKS ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ 5 ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ 4. BATTERY INSTAL
ページ11に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ0-3 SYMBOLS Read the owner's manual. Stay clear of the hot surface. Exhaust gas is poisonous. Do not operate in an unventilated area. Stop the engine before refueling. Fire, open flame and smoking prohibited. Plus ; On (Run) positive polarity Off (Stop) Battery Engine start (Elec- Engine oil tric start) Add oil
ページ12に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ1 1. SAFETY PRECAUTIONS Please make sure you review each precaution carefully. EXHAUST PRECAUTIONS Never inhale exhaust gas. It contains carbon monoxide, a color- less, odorless and extremely danger- ous gas which can cause uncon- sciousness or death. Never operate the engine indoors or in a poorly ventilated area, such as tunnel, cave, etc. Exercise extreme care when operat- ing the engine near people or animals. Keep the exhaust pipe free of
ページ13に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ2 PROTECTIVE COVER Place the protective covers over the rotating parts. If rotating parts such as the drive shaft, pulley, belt, etc. are left exposed, they are potentially hazardous. To prevent injury, equip them with protective covers or shrouds. Be careful of hot parts. The muffler and other engine parts become very hot while the engine is running or just after it has stopped. Operate the engine in a safe area and keep children away from the
ページ14に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ3 Drain the fuel when transporting the engine. Do not move the engine while in operation when it has been removed from the equipment. Keep the unit dry (do not operate it in rainy conditions). PRE-OPERATION CHECKS. Carefully check fuel hoses and connections for looseness and fuel leakage. Leaking fuel creates a potentially dangerous situation. Check bolts and nuts for looseness. A loose bolt or nut may cause seri- ous engine trouble. Check t
ページ15に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ4 2. COMPONENTS REMARKS : Fuel tank, valve (sediment bowl type is recommended), fuel hoses, and fuel filter are r
ページ16に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ5 3. PRE-OPERATION CHECKS (DAILY) CHECK ENGINE OIL Before checking or refilling engine oil, be OIL GAUGE sure the engine is not running and is located on a stable, level surface. If the oil level is below the lower level UPPER LEVEL line on the oil gauge, refill with the proper oil (see table) to the upper level. OIL CAPACITY : 52.48 oz. (1.55 liter) When filling oil in the engine, keep LOWER LEVEL the engine level and fill the oil up to the upp
ページ17に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ6 CHECK FUEL WARNING FUEL PUMP Do not refuel while smoking, near an open flame or other potential hazards. The fuel tank shall be provided sepa- rately, because the engine is not equipped with a fuel tank. A fuel valve and fuel filter should be FUEL INLET connected between the fuel tank and fuel pump. Securely connect with fuel hoses to the fuel pump to prevent leakage. Fuel tank may be mounted up to .66 meters (2 feet) below the carburetor. If
ページ18に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ7 4. BATTERY INSTALLATION For electric starter operation, proper electric wiring arrangements are needed before normal engine operation. PARTS NEEDED Use a battery rated 12V-30AH or larger. Use a proper cable and ground wire to connect battery and key switch and electric starter. BATTERY CABLE WIRE GAUGE CABLE CABLE AWG (BS) LENGTH DIA. SAE JIS BWG Less than 7.3 mm 1 6 AV15 CABLE 1.5 m 1.5 m 8.5 mm 0 4 AV20 to 2.5 m LA406 LA408 2.5 m 10.8 mm 3/0
ページ19に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ8 WIRING Connect positive terminal of the electric starter and positive termi- nal of the battery with battery cable. Ground negative terminal of the battery to the body of engine or CABLE machine with ground wire. NOTE + - ELECTRIC STARTER Tighten bolts and nuts on terminals BATTERY TERMINAL 12V-30AH securely so they will not be loosened EARTH WIRE by vibration. WIRING DIAGRAM RED CARBURETOR STOP BLACK DIODE KEY SWITCH OIL M WARNING S B LAMP L
ページ20に含まれる内容の要旨
EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ9 5. OPERATING YOUR ENGINE NOTE CHOKE KNOB Following operating method is for the STD type speed control lever. 3 As to the fixed type speed control lever (exp. Generator spec.), do not move it otherwise the genera- tor component such as voltage regulator may be damaged. CLOSE Pull the choke knob. STARTING If the engine is cold or the ambient temperature is low, pull the choke FUEL VALVE knob fully. 1 If the engine is warm or the ambient tempera
