Summary of the content on the page No. 1
Electronic Air Cleaner
Model Number
CSC1000
UL Listed
CSA Certified
OWNER’S MANUAL
• Installation
• Operation
• Basic Service Guide
• Technical Repair Guide
• Repair Parts
Please read and familiarize yourself with the contents of this manual before
installing, operating or performing maintenance on the unit.
White-Rodgers is a division
PART NO. 37-6336A
of Emerson Electric Co.
Replaces 846-0273
www.white-rodgers.com
Printed In U.S.A.
0102
Summary of the content on the page No. 2
RULES FOR SAFE 1. Read the Owners Manual and the Rules for Safe INSTALLATION AND OPERATION Operation carefully. Failure to follow these rules and instructions could cause a malfunction of filter or Please read instructions before installing and using the Elec- unsatisfactory service. tronic Air Cleaner. This will help you obtain the full benefit from 2. Follow a regular service and maintenance schedule the Electronic Air Cleaner you have selected. for efficient operation. ! WARNING ▲ ! WARNING ▲
Summary of the content on the page No. 3
Clean Clean Air Out Air Out Charcoal Filter Reduces Odors Collecting Plates attract and hold dirt particles like a magnet Ionizing wires give dirt particles a positive charge Prefilter Screen DIRTY AIR IN FIG. 1 Illustration of Air Cleaning Process INSTALLATION Mounting Detail PLACEMENT The installer must be qualified to make approved electrical Be sure to select the mounting location so that the structure connections and a safe ceiling installation with attention to the above is sufficiently st
Summary of the content on the page No. 4
WIRING INSTRUCTIONS BOX (INTERNAL) Standard electrical wiring of 120 volts, 60 Hz, 15 Amp circuit is TOP OF UNIT adequate. Local residential and commercial wiring codes shall apply. Flexible conduit should be used (Fig. 5). GREEN FIELD GROUND WHITE FIELD NEUTRAL BLACK FIELD HOT FIG. 5 Electrical connection OPERATION/MAINTENANCE OPERATION 1. With the 120 VAC power turned on, adjust the knob to the 3. The Operating Light should be ON whenever the fan is position desired. running. An occasional fli
Summary of the content on the page No. 5
TECHNICAL REPAIR GUIDE ! WARNING ▲ This guide contains service checks to assist service personnel Do not attempt repair of this unit unless you are in locating and correcting any malfunction that might occur to familiar with the necessary tools, equipment, utility render the air cleaner ineffective or inoperative. The air cleaner connections and potential hazards. has been designed with replaceable components, such as the high-voltage power supply. This allows the serviceman to Repair should be
Summary of the content on the page No. 6
OZONE REDUCTION All electronic air cleaners typically produce a small amount of ozone that is within established limits. Some customers may notice an odor especially at high altitudes or low air flow rates. This power supply has a “hairpin” shaped jumper wire labeled W1 W1 that can be cut and separated in case of such complaints. This will cause the power supply to limit the maximum operating Cut and separate power to a lower level. Ozone Reduction Jumper WHT/BRN BLK E3 E2 LINE CSC1000 WIRING DI
Summary of the content on the page No. 7
REPLACEMENT PARTS DIAGRAM 6 7 3 1 9 2 5 11 4 10 8 ITEM NO. DESCRIPTION CSC1000 1 Pre-Filter F825-0357 2 Collecting Cell F811-0414 3 Power Supply † F858-1002 4 Switch, Safety F876-0199 5 Switch, Variable Speed F876-0203 6 Fan Motor F849-0060 7 Fan Blade F848-0315 8 Charcoal Filter F825-0460 9 Light F844-0143 10 Knob F839-0019 11 Ionizing Wire F843-0500 †† Manual 37-6336 † F858-1002 Kit includes Air Flow Switch not used on this model ††Not Shown 7
Summary of the content on the page No. 8
WASH REMINDER SCHEDULE frequent washing may be necessary on some installations where there is new carpeting, plaster dust or excessive cigarette A regular washing schedule is necessary to ensure proper smoke, etc. (See page 4 for maintenance and instructions on efficiency. A thorough washing once every month will be ad- how to clean a cell.) equate for most installations. More or Less Year JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC 20___ 20___ 20___ 20___ 20___ 20___ 20___ 20___ 20___ 20___
