Summary of the content on the page No. 1
TABLE OF CONTENTS
SAFETY CLEANING & MAINTENANCE
Warnings and Notices ................................ 2 Racks ........................................................ 32
Safety Instructions .................................... 4-5 Cleaning the I.R. Burner ............................ 32
Spiders and Other Insects Warning .......... 17 Drip Tray .................................................... 33
Before Using your Grill ............................... 17 Ceramic Briquettes and Radiant Trays ..
Summary of the content on the page No. 2
WARNINGS AND NOTICES safety WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. WARNING: For outdoor use only. Never use this or any other grill or barbecue indoors. Do not use for space heating. NOTICE: All gas installations, conversions, and/or adjustments must be performed by an authorized service agent. General Safety Requirements 1. Installation of this appliance must conform with local codes
Summary of the content on the page No. 3
Steps to follow CONSUMER INFORMATION steps to follow Locate the model and serial numbers. Your new grill model and serial numbers are included on a nameplate located on the outside rear wall of the grill (see illustration below). Complete and return the warranty card. Please take a moment to fill out and mail the Warranty Card included with your Dynasty Grill. Make sure you enter the model and serial numbers of your new appliance on the Warranty Card. For future reference, record the following i
Summary of the content on the page No. 4
SAFETY INSTRUCTIONS Please read before installing and operating your new Dynasty Grill safety General Precautions 1) Your Dynasty gas grill should be properly installed 9) Never grill without the drip pan in place and inserted all the way to the rear of the grill. Hot grease can and serviced. Refer to the installation instructions travel downward and produce a fire or explosion provided in this manual. Ask the installer where the gas supply shut-off is located and how to operate it. hazard. All
Summary of the content on the page No. 5
Safety SAFETY INSTRUCTIONS (continued) safety 4) Do not use water on grease fires. Never pick up a Precautions Regarding Children flaming pan. Turn appliance off and smother the flaming pan with a tight-fitting lid, cookie sheet 1) Never leave children unattended in the area where or flat tray. For flaming grease outside of the pan, the grill is being used. smother with baking soda, or use a dry chemical or foam type fire extinguisher. 2) Do not store items of interest to children around or belo
Summary of the content on the page No. 6
INSTALLATION OF YOUR DYNASTY GRILL installation Safe and satisfactory operation of your Dynasty grill depends qualified installers and service technicians. This is upon its proper installation. The installation, adjustments and necessary to insure proper operation and also to prevent service of your Dynasty grill must be performed only by accidents. Location When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas su
Summary of the content on the page No. 7
Installation DYNASTY CUT OUT DIMENSIONS FOR GAS GRILL AND ACCESSORIES installation DSBA DBQ DBTA DWD-30 DWD-30 DYNASTY DADA WARMING DRAWER E F DWD-30 28 1/4 9 3/4 (71.75 cm) (24.75 cm) DSDA Note: Minimum depth 21 (53 cm) DADA DYNASTY ACCESS DOORS DBQ DYNASTY BUILT-IN GRILLS E F MODELS NON COMBUSTIBLE COMBUSTIBLE A B C D A=B C D DADA - 18 16 1/4 19 3/8 DBQ30 30-1/8 29 24-1/2 11-1/4 29-7/8 25-1/8 12-1/4 (41.25 c
Summary of the content on the page No. 8
INSTALLATION OF YOUR DYNASTY GRILL (continued) installation Gas Requirements Your Dynasty grill is designed to work with Natural or Propane Gas. Check your rating plate to make sure the gas supply provided is the gas type listed on the rating plate (see page 3). An installer supplied gas shut-off valve must be located in an easily accessible location. Use only pipe sealant that is an approved type and is resistant to the actions of propane gas. IMPORTANT: Your Dynasty grill must use the gas t
Summary of the content on the page No. 9
Installation FLIP CAP FOR PROPANE GAS PLUMBED IN CONNECTION installation ELBOW MAY BE ROTATED FOR REAR GAS CONNECTION CUSTOMER SUPPLIED GAS SHUT OFF VALVE Typical Propane Gas Connection REMOVE CONVERTIBLE REGULATOR. INSTALL FLARE ELBOW INCLUDED IN KIT. 20 LB (5 GALLON) PROPANE CYLINDER DO NOT PLACE MORE REGULATOR WITH HOSE. THAN ONE CYLINDER IN THE FOR SELF-CONTAINED ENCLOSURE AT ANY TIME. OPERATION PROVIDED CYLINDERS THAT ARE NOT IN KIT. CONNECTED FOR USE SHALL NOT BE STORED IN THE VICINITY O
Summary of the content on the page No. 10
installation NOTE: An enclosure for a propane gas cylinder shall be vented by openings on the level of the cylinder valve and at floor level. The effectiveness of the opening(s) for purposes of ventilation shall be determined with the propane gas supply cylinder in place. This shall be accomplished by one of the following: a. One side of the enclosure shall be completely open; or, b. For an enclosure having four sides, a top and a bottom: 1. At least two ventilation openings at cylinder valve l
Summary of the content on the page No. 11
Installation INSTALLATION OF YOUR DYNASTY GRILL (continued) installation Adjustments and Efficiency Prior to shipment each burner is tested and adjusted at the factory. Due to variations in the location, conditions, gas supply or when converting from one gas to another, readjustment of the burners may be necessary. The flames of the burners (except the rotisserie burners) should be visually checked and compared to that of the figure on the right. Flames should be blue and stable with no yellow t
Summary of the content on the page No. 12
installation Air Shutter Adjustment (continued) 1. Repeat procedure for each burner requiring adjustment. Be sure to tighten air shutter setscrews when finished. 2. Once adjusted, turn the burner OFF and reverse steps to reassemble. Low Setting Adjustment Grill and Open Burners The valves on your Dynasty grill feature an adjustable low setting. Due to fluctuations in gas pressure, heating value or gas conversion, you may feel it necessary to increase or BEZEL decrease gas flow in the low positio
Summary of the content on the page No. 13
Installation INSTALLATION OF YOUR DYNASTY GRILL (continued) installation Leak Testing Perform a leak test at least once each year whether the gas supply cylinder has been disconnected or not. In addition, anytime the gas cylinder is connected to the regulator or any part of the gas system is disconnected or replaced, conduct the leak testing. This applies to natural gas as well as propane gas. As a safety precaution, remember to always leak test your grill outdoors in a well ventilated area. Nev
Summary of the content on the page No. 14
installation Leak Testing Procedure (continued) 7. If you are unable to stop a leak, shut off the gas supply at the cylinder valve. Remove the cylinder from the grill. Call an authorized gas appliance service technician or LP gas dealer. Do not use the appliance until the leak is corrected. 8. Push in and turn any control knob to release pressure in the hose and manifold. 9. Turn off the control knob. Installing the Heat Deflector The Heat Deflector should be fully inserted in its position, as s
Summary of the content on the page No. 15
Installation Installing Access Doors installation Models DADA-18, DADA-30 and DADA-42 1. Provide cut out and doorjamb with inside dimensions as 5. Adjust doors as follows: follows: 19 3/8" X 16 1/4" for DADA-18, 19 3/8" X 28 a) For height adjustment, loosen the two screws 1/4" for DADA-30, and 19 3/8" X 40 1/4" for DADA-42 attached to each mounting plate. (See figure A) 2. Check fitting of frame against cutout. Mark location of b) Snap off hinge and secure mounting plate with rivet nuts. #6 X 1
Summary of the content on the page No. 16
FEATURES OF YOUR GRILL Operation Feature Index See page 1 Grill Operation 18-20 Cleaning and Maintenance 32-35 2 Top Burners Operation 24-25 Flame Size 25 3 Smoke Drawer Operation 21 4 Rotisserie Operation 22-23 5 Grill Racks Cleaning 32 6 Drip Tray Cleaning 33 7 Exterior Surfaces Cleaning 33 8 Battery Igniter Maintenance 35 9 Questions? Easy Troubleshooting Guide 36-37 16
Summary of the content on the page No. 17
Safety SPIDERS AND OTHER INSECTS WARNING… safety Spiders and other insects can nest in the burners of the grill and block the gas and airflow to the burner ports. This creates a dangerous condition that can result in a fire from behind the valve panel. It is good practice to inspect the burners for blockage and clean them regularly; in addition, such inspection and cleaning is absolutely necessary if any of the following conditions exists: a) Smell of gas in conjunction with a yellow flame. b) G
Summary of the content on the page No. 18
USING YOUR GRILL Operation Your Dynasty grill consists of a set of U-burners, a bed of and debris. Also available in some models are IR burners ceramic briquettes and a heat retaining cooking rack. providing intense infrared radiant heat. This type of heat Located above the burners, the stainless steel trays allows proper searing and browning as well as even supporting the ceramic briquettes protect the burner ports cooking of meats. Grease and food particles are from blockage. Each burner is ra
Summary of the content on the page No. 19
Operation Operation Operating The Grill Make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is present. For propane grills, check the connection with a soap and water solution after attaching the hose. Make sure there is gas in the tank and it is sitting upright. 1. Make sure the drip tray is in place. 2. Light the grill burners using the instructions below. 3. Turn the control knob to HI and preheat the grill for 15 minutes. The top cover should be clo
Summary of the content on the page No. 20
USING YOUR GRILL (continued) operation Lighting The Grill Burners 7. Repeat the procedure or try “Manual Lighting procedure” below. 8. Upon successful lighting, repeat the process on the other burners you wish to light. 9. To shut off burners push in knob and turn to OFF. It is normal to hear a popping sound when the burners are turned off. Manually Lighting The Grill Burners 1. Open the hood. 2. Remove the grates over the burners you wish to light. 3. If you have just attempted to light the bu
