Summary of the content on the page No. 1
Dell™ Inspiron™ 9300 Service Manual
Before You Begin Speakers
System Components Subwoofer
Optical Drive USB Port Board
Hard Drive Microprocessor Thermal-Cooling Assembly
Memory Module Microprocessor Module
Modem Video Card/Thermal Cooling Assembly
Mini PCI Card System Fans
Internal Card With Bluetooth® Wireless Technology MCH Heat Sink
Hinge Cover PC Card Cage
Keyboard System Board
Display Battery Latch Assembly
Palm Rest Flashing the BIOS
Coin-Cell Battery Pin Assignments for I/O Connectors
Summary of the content on the page No. 2
Back to Contents Page Before You Begin Dell™ Inspiron™ 9300 Service Manual Recommended Tools Turning Off Your Computer Before Working Inside Your Computer Computer Orientation Screw Identification This section provides procedures for removing and installing the components in your computer. Unless otherwise noted, each procedure assumes that the following conditions exist: l You have performed the steps in "Turning Off Your Computer" and "Before Working Inside Your
Summary of the content on the page No. 3
3. Disconnect any telephone or network cables from the computer. 4. Disconnect your computer and all attached devices from their electrical outlets. 5. Close the display and turn the computer upside down on a flat work surface. NOTICE: To avoid damaging the system board, you must remove the main battery before you service the computer. 6. Slide the battery-bay latch release on the bottom of the computer and remove the battery from the bay. 7. Turn the computer
Summary of the content on the page No. 4
When you are removing and replacing components, print "Screw Identification" as a tool to lay out and keep track of the screws. The placemat provides the number of screws and their sizes. Optical Drive: Hard Drive: Modem: (1 each) (2 each) (1 each) Internal Card With Bluetooth® Wireless Technology: Keyboard: Display Assembly: (1 each) (2 each) (4 each) Display Bezel: Display Panel: Palm Rest: (4 each, under rubber display bumpers) (8 each) (7 each – top side)
Summary of the content on the page No. 5
MCH Heat Sink: PC Card Cage: System Board: (3 each) (4 each) (3 each) Hard Drive Bay: Stiffener Bracket: (4 each) (1 each) Back to Contents Page
Summary of the content on the page No. 6
Back to Contents Page System Components Dell™ Inspiron™ 9300 Service Manual NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure in this document assumes that a part can be replaced by performing the removal procedure in reverse order. 1 display assembly 12 speakers (2) 2 hinge cover 13 subwoofer 3 keyboard 14 opt
Summary of the content on the page No. 7
Back to Contents Page Optical Drive Dell™ Inspiron™ 9300 Service Manual Your computer ships with a fixed optical drive installed. NOTICE: To prevent damage to drives, store them in a safe, dry place when they are not installed in the computer. Avoid pressing down on them or placing heavy objects on top of them. 1. Follow the instructions in "Before Working Inside Your Computer." 2. Turn the computer over and remove the M2.5 x 8-mm security screw labeled with a lock icon (
Summary of the content on the page No. 8
Back to Contents Page Hard Drive Dell™ Inspiron™ 9300 Service Manual Removing the Hard Drive Replacing the Hard Drive Returning a Hard Drive to Dell Removing the Hard Drive CAUTION: If you remove the hard drive from the computer when the drive is hot, do not touch the metal housing of the hard drive. CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid damaging the system board, you must
Summary of the content on the page No. 9
Returning a Hard Drive to Dell Return your old hard drive to Dell in its original or comparable foam packaging. Otherwise, the hard drive may be damaged in transit. 1 hard drive 2 foam packaging Back to Contents Page
Summary of the content on the page No. 10
Back to Contents Page Memory Module Dell™ Inspiron™ 9300 Service Manual Removing the Memory Module Replacing the Memory Module Removing the Memory Module CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To prevent static damage to components inside your computer, discharge static electricity from your body before you touch any of your computer's electronic components. You can do so by touching an un
Summary of the content on the page No. 11
1 memory module 2 securing clip (2) Replacing the Memory Module NOTE: To get maximum performance/dual-channel memory bandwidth capability, both memory module connectors must contain memory modules and the modules must be of the same size and configuration. NOTE: If a memory module is not installed properly, the computer will not boot. 1. Ground yourself and install the new memory module: a. Align the notch in the module edge connector with the tab in the connector slot. b. S
Summary of the content on the page No. 12
Back to Contents Page Modem Dell™ Inspiron™ 9300 Service Manual Removing the Modem Replacing the Modem Removing the Modem CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. NOTICE: To avoid damaging the system board, you mu
Summary of the content on the page No. 13
5 system board connector NOTICE: Do not disconnect the modem cable from the system board. 5. Disconnect the modem cable from the modem. Replacing the Modem 1. Connect the modem cable to the modem. NOTICE: Ensure that the modem cable is routed correctly when you replace the modem. 2. Connect the modem to the system board. Align the connector on the bottom of the modem with the modem connector on the system board, and press down on the right side of the modem. 3. Rep
Summary of the content on the page No. 14
Back to Contents Page Dell™ Inspiron™ 9300 Service Manual NOTE: A NOTE indicates important information that helps you make better use of your computer. NOTICE: A NOTICE indicates either potential damage to hardware or loss of data and tells you how to avoid the problem. CAUTION: A CAUTION indicates a potential for property damage, personal injury, or death. For a complete list of abbreviations and acronyms, see the Dell Inspiron Help file. To access the help file, click the Start button,
Summary of the content on the page No. 15
Back to Contents Page Mini PCI Card Dell™ Inspiron™ 9300 Service Manual Removing the Mini PCI Card Replacing the Mini PCI Card Removing the Mini PCI Card CAUTION: If you are removing and/or installing a 2.4-GHz (802.11b, 802.11b/g) Mini PCI card, follow the instructions noted below. Only products approved for use in your portable computer may be installed. Approved Mini PCI cards may be purchased only from Dell. CAUTION: Before you begin the following procedure, see
Summary of the content on the page No. 16
5. Release the Mini PCI card by spreading the metal securing tabs until the card pops up slightly. 6. Remove the Mini PCI card from the connector at a 45-degree angle. 1 Mini PCI card 2 metal securing tabs (2) Replacing the Mini PCI Card NOTICE: To avoid damaging the antenna cables or the Mini PCI card, never place the cables under the card. NOTICE: The connectors are keyed to ensure correct insertion. If you feel resistance, check the connectors and realign the card.
Summary of the content on the page No. 17
1 antenna cables (2) 3. Replace the cover. Back to Contents Page
Summary of the content on the page No. 18
Back to Contents Page Internal Card With Bluetooth® Wireless Technology Dell™ Inspiron™ 9300 Service Manual Removing the Card Replacing the Card Removing the Card CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. NOTICE: T
Summary of the content on the page No. 19
Back to Contents Page Hinge Cover Dell™ Inspiron™ 9300 Service Manual Removing the Hinge Cover Replacing the Hinge Cover Removing the Hinge Cover CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. NOTICE: To avoid damaging
Summary of the content on the page No. 20
Back to Contents Page Keyboard Dell™ Inspiron™ 9300 Service Manual Removing the Keyboard Replacing the Keyboard Removing the Keyboard CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. NOTICE: To avoid damaging the system b
