Summary of the content on the page No. 1
up to99%
Efficiency!
Can be vented with PVC
MBTU Models
300 • 400 • 500 • 700 • 850
CSA Verified lead Content
Less Than .25% Pb Ultra Low Emissions
Summary of the content on the page No. 2
Xtreme Outdoor Performance Up to99% part load! XFyreT Condensing Modulating Boiler Vent Flexibility Category IV -CSA-certified 94% efficiency at - The Green Choice full fire for hydronic boilers and 95% for domes- Raypak’s new XFyreT is a natural extension of our successful tic water heaters (Up to 99% at part load!) XThermT modulating vertical boiler line (1,1.5, 2 Million BTUH). Raypak When the job requires high efficiency, XFyre offers new features not found in other mod-con style boilers an
Summary of the content on the page No. 3
Model 850 Model 300 1. Water Inlet 5. Air Fuel Ratio Gas Valve 12. Direct Spark Ignition As low as 50°F entering. All copper and brass factory XFyre uses a German, precision manufactured, main XFyre's state-of-the-art combustion control system installed vertical plumbing connections. Vertical gas valve considered by most to be second to none. utilizes the finest dual electrode igniter to start the plumbing allows boilers to be installed side by side or This high tech gas valve works in perfect u
Summary of the content on the page No. 4
Xtreme Access The XFyre is purpose built for the contractor and service professional. 7 4 8 Completely serviceable from the front, top and both sides! 1. Flue Outlet 5. Direct Vent Capability 8. Inlet and Outlet Connections and Flow Switch Category IV- PVC, CPVC and Stainless steel certified. Every XFyre is direct vent capable. By installing an The vertical inlet and outlet connections are all copper and brass fitted with male pipe thread connections. The XFyre ships PVC ready, no extras to pur
Summary of the content on the page No. 5
Xtremely Small Footprint Dimensions (in.) Ship Foot- Model Weight Print Amps* A E F G H T V K 2 (lbs.) (ft ) Length Mounting NPT NPT Flue Ø C/A Ø 3 0 0 28 - 1/4 16 - 1/2 27 - 9/16 3 / 4 1 - 1/2 4 4 3 4 1 0 4 . 3 3 4 0 0 30 - 3/4 16 - 1/2 29 - 3/4 1 2 4 4 3 4 6 5 4 . 7 4 5 0 0 37 - 1/4 16 - 1/2 36 - 1/4 1 2 4 4 3 5 0 5 5 . 7 4 7 0 0 47 - 3/4 2 8 47 - 1/16 1 - 1/4 2 6 6 19 - 3/8 5 5 0 7 . 3 5 8 5 0 54 - 1/4 2 8 53 - 9/16 1 - 1/4 2 6 6 19 - 3/8 5 8 0 8 . 3 5 Ratings shown are for elevations up to 1
Summary of the content on the page No. 6
Xtremely Easy to Wire 120VAC Wiring Center The XFyre’s 120VAC wiring center is located on the rear of the boiler. All incoming line voltage and pump wiring are contained away from the 24v control wiring. Wiring the boiler is simple and straight forward. Low Voltage Wiring Center Just like its big brother the XTherm, the XFyre has a separate front mounted wiring center for all of the low voltage connections. This makes thermostat, water sensor, 0-10VDC BMS, and alarm contacts a breeze to set up.
Summary of the content on the page No. 7
Xtreme Control Boiler Control and On-Board Diagnostic Center Raypak’s XFyre comes equipped with a microprocessor control center that displays its information on a 2x20 character LCD display in plain English. All set-up and programming is done at this interface. Control monitors boiler system status including safeties, ignition faults and also stores up to 10 reported faults. The diagnostic center even monitors and reports the flame strength signal in microamps. Monitor blower speed, BMS input a
Summary of the content on the page No. 8
Water Heaters Boilers (Type WH) (Type H) ASME Section IV, National Board Registered, 160 PSI • H Stamp v v Heat Exchanger Tubes • 316L Stainless Steel v v Stainless Steel • CSA Verified AB-1953 CA low lead compliant v v Pressure Relief Valve • 60 PSI V v (loose) • 125 PSI v V • 30, 45, 75, 150 PSI V V Temperature & Pressure Gauge (Loose) v v Pump • 120V, Single-Phase V V Indoor/Outdoor Certified v v Vent Terminal • Outdoor V V • Through-the-Wall V V Fully-Enclosed Controls v v Combustible Floor
