Summary of the content on the page No. 1
January 2004
X-10SW Hand-held Sprayer X-10SW Hand-held Sprayer X-10SW Hand-held Sprayer X-10SW Hand-held Sprayer X-10SW Hand-held Sprayer
(Accessory To X-10 OC Chemical Delivery Systems)
Operating and
Maintenance Instructions
Summary of the content on the page No. 2
© Priax Corporation P.O. Box 776 • 33408 Sandy Creek Lane Phone 619.478.2600 • Fax 619.478.2555 www.priaxcorp.com
Summary of the content on the page No. 3
Table of Contents Introduction 1 Warnings 2 Features 2 Optional Accessories 3 Operating Specifications 3 Connection to X-10C Chemical Cylinder 4 Pre-operational Use 4 Operation of the X-10SW Hand-held Sprayer 4 After Using or When Refilling the X-10SW with X-10C Chemical Cylinder Attached 5 Limited Warranty 8 Technical Support 8 Replacement Parts 9
Summary of the content on the page No. 4
Summary of the content on the page No. 5
Operating and Maintenance Instructions Introduction This manual will prepare site personnel to operate the X-10SW Handheld Sprayer. An orientation and training video can be used in conjunction with this manual. If you feel that additional instruction or procedures are necessary, please contact the factory regarding a training class. The X-10SW provides the ability to utilize the X-10C chemical cylinder with a handheld sprayer. The X-10SW sprayer has a pressure washer gun- grip handle with replac
Summary of the content on the page No. 6
Operating and Maintenance Instructions Warnings The X-10SW Hand Held Sprayer must not be used by any officer until that officer has received training in X-10SW operation and the officer has also test fired the X-10SW. IMPORTANT - The X-10SW is a high pressure gas less-lethal weapon. Careful handling and proper training is required. The X- 10SW high pressure hose contains Oleoresin Capsicum (pepper spray) under high pressure when the X-10C valve is opened. The pressure MUST BE RELEASED BEFORE the
Summary of the content on the page No. 7
Operating and Maintenance Instructions Optional Accessories 5-inch straight bore tip 5-inch “Salinas” wide-angle spray tip Wide-angle fog tip 26-inch flexible hose tip Operating Specifications Spray force: 15 ft. lbs. at 3 feet, using straight bore nozzle Note: For ballistic test results, contact the factory. Recommended minimum shooting distance: 5 feet Do not shoot at head area within 8 feet for “Salinas” tip. Do not shoot at head area within 12 feet for straight bore tip. Average shots: 1-l
Summary of the content on the page No. 8
Operating and Maintenance Instructions Connection to X-10C Chemical Cylinder Verify that the X-10C chemical cylinder valve is closed before attempting to attach the X-10SW hose. Carefully attach the X- 10SW hose and verify that the connector is properly seated. Attach the X-10SW safety chain to the hole in the X-10C pres- sure gauge shroud. Verify that the safety on the spray wand pistol grip has been set before proceeding. DO NOT open the X-10C chemical cylinder valve until you are preparing to
Summary of the content on the page No. 9
Operating and Maintenance Instructions Operation of X-10SW Handheld Sprayer The X-10SW must be used in strict conformation with the Department Operational Procedures. 1. Place the X-10C chemical cylinder in the fabric carrier. 2. Fasten the Velcro flap and hose straps so the bottle cannot slip out of the fabric carrier. 3. Place the carrier on your back in the same manner that you would any backpack. 4. Fasten the chest strap and arrange the hose for either right-hand or left-hand operation as d
Summary of the content on the page No. 10
Operating and Maintenance Instructions safe direction to release the remaining hose pressure. The pepper spray residue in the hose may drip if not contained. Whenever refilling the X-10C chemical cylinder, be sure to follow the procedures contained in the X-10OC Extension Device, Operating and Filling Instructions. IMPORTANT - The X-10SW is a high pressure gas less-lethal weapon. Careful handling and proper training is required. The X- 10SW high pressure hose contains Oleoresin Capsicum (pepper
Summary of the content on the page No. 11
Operating and Maintenance Instructions 7
Summary of the content on the page No. 12
Operating and Maintenance Instructions Limited Warranty Priax Corporation makes no warranty, expressly or by implication, except as set forth below. Priax Corporation warrants that the products delivered hereunder will be in substantial conformity with applicable specifications and will be free from defects in material and workmanship. Priax Corporation’s obligation under this warranty shall be limited to (at its option) repairing, replacing, or granting a credit at the prices invoiced at the ti
Summary of the content on the page No. 13
Operating and Maintenance Instructions Replacement Parts Replacement Components Part No. Description X-10SW-210 Pistol-grip handle assembly X-10SW-211 Quick-release connector, female for Tip, 1/4 inch X-10SW-212 Straight swivel X-10SW-213 Hose, 5-foot with male fittings X-10SW-214 Rotary joint, 90-degree swivel X-10SW-215 90-degree street ell, 3/8” X-10SW-216 Connector, male, mate to bottle, 3/8” Replacement Tips Part No. Description X-10SW-250 Nozzle tip, straight bore, 6-inch, stainless steel
