Summary of the content on the page No. 1
16”
Maximum
CENTER ACROSS
VEHICLE FRAME
WARNING
P -ha dl i full
u m a s a n h ln o d u T co k aiu b llly te n tf m o or ov e e e n d e n g p r ag iv la e in ty fo p ga lrm a v ne td fo hin r ic m le .
Fr ae ds u e u p re la ltlo t t fio y n or m u lo m e nc nin ktte .pl pl U n an d tfe in or m dte m p n nt la m de tm a fd o yrm
pre as nud/ lt i or nd p s e re ori p o o e yus rtye b do adm ila y ag yin e .jury
Do not remove 8! 1823
Braun Corporation FMVSS No. 403 Quick Reference Installation S
Summary of the content on the page No. 2
VEHICLE BOX FRAME 16” Maximum WARNING Pm ush anu T- ah lland y mlo evie np fu lalt ly foand rm in an lo d F ck r ai o es lu b ut u e rt le fto ot ir n o en eu ld o g n r ck a iig n vit e p ng elpl n ad ta v fed t o eh fo rm ir p c m lla m et.f ao yrm dp ep r la e a lt o sul n fy o d men r/tm oir nd p ts e .re p oU ri lpe o o ny u irn m ts y te en b da n ot d d m m ed ila y ag y ie nj .ury Do not remove 8! 1823 Braun Corporation FMVSS No. 403 Quick Reference Installation Sheet 32553 Rev. A Secure
Summary of the content on the page No. 3
Power Cable LIFT STOWED SIGNAL (Yellow/Light Blue) VEHICLE SECURE SIGNAL (Grey/Red) Pos. Neg. Mount Pump Min. Vertical 1-3/4” to Wall Pump must face Out To Interlock Braun Corporation FMVSS No. 403 Quick Reference Installation Sheet 32553 Rev. A Electrical, Hydraulic and Interlock 3 Jumper Wire 5/16" Pump Module Mounting Hydraulics: Circuit Sentry: Lag Bolts Figure K (typical - 4) Install black jumper wire Mount reinforcement “L” bracket Remove the plug last. Install the black jumper to pu
Summary of the content on the page No. 4
1 2 3 4 5 6 7 8 9 10 12 3 4 5 67 8 9 10 Braun Corporation FMVSS No. 403 Quick Reference Installation Sheet 32553 Rev. A FMVSS 403/404 Certification Checklist 5 Door Operators/Switch, Terminal 4 Visual and Audible Strip and Floor Level Adjustment Threshold Warning DOT — Public Use Lift Public use vehicle manufacturers Terminal Strip Power Door Operators are responsible for complying with the lift lighting requirements in Fed- To Door Openers The pump-mounted Install optional “Open” Trigger C_
Summary of the content on the page No. 5
Braun Corporation FMVSS No. 403 Quick Reference Installation Sheet 32553 Rev. A Lift Operating Instructions Lift Operating Instructions Lift Operating Instructions Note: The instructions out- folding handrails and a dual Handrails and Dual Outer Barrier: lined here are applicable for outer barrier system. The folding handrails and tall outer OPEN DOOR(S) AND SECURE TO LOAD PASSENGER: “Public-Use” NUVL lift mod- barrier are manually operated. The els equipped with dual Before lift operation, p
Summary of the content on the page No. 6
P P O O E E S S O O L L C C WARNING Push T-handle in fully and manually move platform in and out to engage platform lock before driving vehicle. Failure to lock platform may result in unintended platform deployment. Un platform deployment may intended result in serious bodily injury and/or property damage. 81823 Do not remove! WARNING Push T-handle in fully and manually move platform in and out to engage platform loc Fail k b ure efor to l e dr ock p iving latve f h rm icl may e. res
Summary of the content on the page No. 7
WARNING Pm ua s an h n d u Ta -h o llu a y tn tm d o l o e ev in e n g a p flu g la e lty fp o la ra m n tfd i on rm l o F cr a k ie ld s b e uu e r p le fto o itr y n o e m lu d o e n r c iin k v n itpl e nUn g n at d v fe e o n d r h im e pl c n la m d e.te fad o yrm p lra le a ts fnu o d l/rtm o i r n d p ts .e re p op lrio o e iyu rm ty s teb d n o a tdi m m l a y ag iye n .j ury Do notremov 8e 18! 23 Braun Corporation FMVSS No. 403 Quick Reference Installation Sheet 32553 Rev. A Maintenance
Summary of the content on the page No. 8
Braun Corporation FMVSS No. 403 Quick Reference Installation Sheet 32553 Rev. A Maintenance and Lubrication Hydraulic Fluid (Pump) - Check level. Note: Fluid Use 5606 aviation fluid only (part 87010R-MILL). should be changed if there is visible contamina- Check fluid level with platform lowered fully. tion. Inspect the hydraulic system (cylinder, hoses, Fill to within 1-1/2" of the bottom of the fill tube fittings, seals, etc.) for leaks if fluid level is low. (neck). Carriage and eccentric shaft
