Summary of the content on the page No. 1
3308120.XXX GENESIS AIR FILTRATION SYSTEM
3308120.XXX
GENESIS AIR FILTRATION SYSTEM
FOR
57XXX SERIES
USA
SERVICE OFFICE
59XXX SERIES
Dometic Corp.
509 So. Poplar St.
LaGrange, IN 46761 600XXX SERIES
260-463-4858
620XXX SERIES
CANADA
630XXX SERIES
Dometic Dist.
866 Langs Dr.
AIR CONDITIONERS & HEAT PUMPS
Cambridge, Ontario
CANADA N3H 2N7
USED WITH
519-653-4390
For Service Center
3109226.005 ELECTRONIC CONTROL KIT
Assistance Call:
800-544-4881
3109407.001 ELECTRONIC CONTROL KIT
3107541.009 ANALOG
Summary of the content on the page No. 2
3308120.XXX GENESIS AIR FILTRATION SYSTEM NOTES: 2
Summary of the content on the page No. 3
3308120.XXX GENESIS AIR FILTRATION SYSTEM 1. GENERAL INFORMATION SAFETY INSTRUCTIONS A. The Genesis Air Filtrations System is designed for: This manual has safety information and instruc- 1. Installation on a recreational vehicle at the time the vehicle is manufactured. tions to help users eliminate or reduce the risk of 2. Mounting of an air conditioner or heat pump on the accidents and injuries. roof of a recreational vehicle. 3. Roof construction with rafters/joists on minimum of RECOGNIZE SA
Summary of the content on the page No. 4
3308120.XXX GENESIS AIR FILTRATION SYSTEM INSTALLATION INSTRUCTIONS 1. PRECAUTIONS C. AFTER LOCATION HAS BEEN SELECTED: 1. Check for obstructions in the area where air condi- ! WARNING tioner/heat pump and return air cover will be in- stalled. Improper installation may damage equip- 2. The roof must be designed to support 130 pounds ment/could endanger life, cause serious in- when the RV is in motion. Normally a 200 lbs. static jury and/or property damage. load design will meet this requirement.
Summary of the content on the page No. 5
3308120.XXX GENESIS AIR FILTRATION SYSTEM C. DUCT SIZING REQUIREMENTS AS FOLLOWS: 4. AIR DISTRIBUTION SYSTEM INSTALLATION NOTE: Duct sizes listed are inside dimensions. Min. Max. Dometic Corporation recommends the basic configuration 1. Duct Depth 2.00" 2-1/2" shown in FIG. 1 for installing this air conditioner/heat pump 2. Duct Width 8.00" 10.00" system. We have found by testing, that this configuration 3. Total Duct Length 15' 40' works best in most applications of this air condi
Summary of the content on the page No. 6
3308120.XXX GENESIS AIR FILTRATION SYSTEM 5. The 14-1/4" (±1/8") opening is part of the return air D. Place the Genesis Air Filtration System and System system of the air conditioner and must be finished in Control Option inside the RV. These boxes contains accordance with NFPA Standard 501C Section 2.7. mounting hardware for the air conditioner/heat pump C. AIR DISTRIBUTION DUCT INSTALLATION and will be used inside the RV. 6. INSTALLATION OF UNIT Install the air distribution ducts in the RV roo
Summary of the content on the page No. 7
3308120.XXX GENESIS AIR FILTRATION SYSTEM c. Peel tape to expose adhesive. Wedge the E. Place the ceiling template up into the return air opening divider between center duct and bottom of in the ceiling. Start each mounting bolt by hand through unit. the ceiling template and up into the base pan. Install a d. Stick foam weather strip (not provided) on wood screw in each end of the ceiling template. This the top side of the ceiling template to seal insures a tight fit of the return air cover to t
Summary of the content on the page No. 8
3308120.XXX GENESIS AIR FILTRATION SYSTEM G. Use Aluminum foil tape (not provided) to seal the ends of C. The “CLEAN FILTER” bulb will blink as a reminder to the foam divider to the sides of the opening. Make sure clean/change the air filter every 60 days. If in dusty the area behind the flange on the ceiling template is conditions, the filter should be checked bi-weekly and clean/changed if needed. sealed. See Figure 9. 1. To clean the filter, remove the dust using a vacuum Use Aluminum Foil Ta
