Summary of the content on the page No. 1
Transport FT48
B4985
Service Engineer’s Manual
Summary of the content on the page No. 2
Summary of the content on the page No. 3
Preface Copyright This publication, including all photographs, illustrations, and software, is protected under international copyright laws, with all rights reserved. Neither this manual, nor any material contained herein, may be reproduced without written consent of the manufacturer. Copyright 2007 Version 1.0 Disclaimer Information contained in this document is furnished by TYAN Computer Corporation and has been reviewed for accuracy and reliability prior to printing. TYAN assumes no lia
Summary of the content on the page No. 4
Federal Communications Commission Notice for the USA Compliance Information Statement (Declaration of Conformity Procedure) DoC FCC Part 15: This device complies with part 15 of the FCC Rules Operation is subject to the following conditions: 1) This device may not cause harmful interference, and 2) This device must accept any interference received including interference that may cause undesired operation. If this equipment does cause harmful interference to radio or television receptio
Summary of the content on the page No. 5
About this Manual This manual provides you with instructions on installing your FT48- B4985, and consists of the following sections: Chapter 1: Provides an Introduction to the FT48-B4985 bare- bone, packing list, describes the external compo- nents, gives a table of key components, and provides block diagrams of the system. Chapter 2: Covers procedures on installing the CPU, mem- ory modules, PCI cards and hard drives. The rackmounting instructions are also given. Chapter 3: Covers removal an
Summary of the content on the page No. 6
Safety Information Before installing and using the FT48-B4985, take note of the following precautions: • Read all instructions carefully. • Do not place the unit on an unstable surface, cart, or stand. • Do not block the slots or openings on the unit which are provided for ventilation. • Only use the power source indicated on the marking label. If you are not sure about your power source, contact the power company. • The unit uses a three-wire grounded cable, which is sup- plied with a th
Summary of the content on the page No. 7
Table of Contents Chapter 1: Overview 1.1 About the TYAN Transport FT48-B4985............................ 1 1.2 Product Model.................................................................... 2 1.3 Features............................................................................. 3 1.4 Unpacking.......................................................................... 4 1.4.1 Box Contents ............................................................... 4 1.4.2 Accessories ...................
Summary of the content on the page No. 8
Chapter 3: Replacing Pre-installed Components 3.1 Introduction ...................................................................... 55 3.1.1 Work Area.................................................................. 55 3.1.2 Tools .......................................................................... 55 3.1.3 Precautions................................................................ 56 3.2 Disassembly Flowchart.................................................... 57 3.3 Removing the Ch
Summary of the content on the page No. 9
Chapter 1: Overview 1.1 About the TYAN Transport FT48-B4985 TM Congratulations on your purchase of the TYAN Transport FT48-B4985, a highly-optimized rack-mountable barebone TM system. The Transport FT48-B4985 is designed to support ® the latest four AMD Opteron™ 8000 series 1207-pin pro- cessor, providing a rich feature set and incredible perfor- ® mance. Leveraging advanced technology from AMD , the TM Transport FT48-B4985 server system is capable of offering scalable 32 and 64-bit computi
Summary of the content on the page No. 10
1.2 Product Model Supported HDD Storage Model Power supply type & quantity backplane SATA/SATA2 (8) 8-port 1140W (2+1) B4985F48V8HR (SAS ready) SAS/SATA redundant, hot swap B4985F48V8HR (Rackmount) B4985F48V8HR (Tower) 2 Chapter 1: Overview
Summary of the content on the page No. 11
1.3 Features Enclosure Storage • Industry 19” rack-mountable 4U & • Supports eight (8) SATA/SATA2 HDD Pedestal convertible chassis with RAID 1, 0, 1+0, 5 • Storage bays • Pre-installed (1) 5.25” type 8x DVD-ROM -(3) 5.25” Driver bays Networking -(8) 3.5” HDD bays • Total three (3) Gigabit Ethernet ports • Dimensions: -Two (2) from Marvell 88E1111 GbE -D 27.5 x W 16.8 x H 6.9 inch -One (1) from Intel 82541PI GbE -D 700 x W 427 x H 176 mm Video Processors • XGI XG20 graphics controller ® • Suppor
Summary of the content on the page No. 12
1.4 Unpacking This section describes the FT48-B4985 package contents and accessories.Open the box carefully and ensure that all components are present and undamaged. 1.4.1 Box Contents Component Description Industry standard 4U chassis with eight HDD bays and three further 5.25-inch device bays Tyan Thunder n4250QE S4985G3NR motherboard (pre-installed) DVD-ROM drive (pre-installed) Two M1211-P SAS/SATA backplanes (pre-installed) M1007 LED control board (pre-installed) M1014 FAN control boa
Summary of the content on the page No. 13
Component Description (6) system cooling fans (pre-installed) 120 x 120 x 38 mm Chapter 1: Overview 5
Summary of the content on the page No. 14
1.4.2 Accessories If any items are missing or appear damaged, contact your retailer or browse to TYAN’s Web site for service: http://www.tyan.com. The Web site also provides information on other TYAN products, plus FAQs, compatibility lists, BIOS settings, and more. Power Cables TYAN Driver CD US x 3; Europe x 3 4 x CPU Heatsinks 4 x Chassis foot stands (including four screws) Keys Barebone Manual & Mainboard Manual TYAN Logo 6 Chapter 1: Overview
Summary of the content on the page No. 15
FDD Cable HDD Screws FDD Front Panel 5 x Long Card Holders (including five screws) Security Tab (including two screws) Sliding Rail Kit Rail assembly 2 x Mounting Ears (including six screws) Screws & Small Brackets Chapter 1: Overview 7
Summary of the content on the page No. 16
1.5 About the Product This section contains hardware diagrams and a block diagram of the FT48-B4985 system. 1.5.1 System Front View and Front Panel See the diagram below for details of the front panel indicators and switches. Power button ID button USB ports Reset button ID LED Power LED LAN2 LED HDD/IDE LED LAN1 LED Hotswap HDD bays (Left to right: HDD1~HDD8) LED control panel DVD-ROM SAS Fail LED (reserved for SAS add-on card) 5.25-inch device HDD Power / bays Access LED 8 Chapter 1: Ove
Summary of the content on the page No. 17
1.5.2 System Rear View Redundant power supply Security slot LAN1 port Expansion VGA slots port ID LED USB ports Stacked keyboard Serial port LAN2 LAN3 AC input and mouse ports (COM 1) port port Redundant PSU reset button NOTE: The buzzer sounds during power failure or abnormal condition. Press the Redundant PSU reset button to return the power supply units to their default states. On the rear of the FT48-B4985, two screw holes are available for you to secure the chassis lid with two screw
Summary of the content on the page No. 18
1.5.3 System Top View for FAN LEDs FAN5 LED FAN3 LED FAN1 LED FAN6 LED FAN4 LED FAN2 LED LED Color Description FAN1/FAN2/FAN3/FA Green Fan is functioning normally. N4/FAN5/FAN6 LED Red Fan fail. 1.5.4 Front LEDs LED Color State Description Power Green ON Power ON OFF OFF Power OFF HDD/ IDE Green Blinking HDD/ DVD-ROM access activity OFF OFF No disk activity LAN1/ LAN2 Activity Green Blinking LAN accessing OFF OFF No LAN linked ID LED Blue ON System is identified OFF OFF System is not identified
Summary of the content on the page No. 19
1.5.5 Rear I/O LEDs LED Status Color Description RJ45 Linkage/ Green ON 10Mb/100Mb/1000Mb linked Activity (Left Side) Green Blinking 10Mb/100Mb/1000Mb activity OFF OFF No LAN linked RJ45 Linkage/ Yellow ON 1000Mb linked/ activity Activity (Right Side) Green ON 100Mb linked/ activity OFF OFF 10Mb mode or No LAN linked ID LED Blue ON System is identified OFF OFF System is not identified Chapter 1: Overview 11
Summary of the content on the page No. 20
1.5.6 Motherboard Layout 12 Chapter 1: Overview
