Resumo do conteúdo contido na página número 1
Owner's Manual
TM
Liquid Propane GasGrill
Model 141.166400
Natural Gas Grill
Modem 141.176400
//.vXk VVARNmNG: Note to Consumer:
Leave this Owner's Manual in a convenient place
Read this Owner's Manual carefully and besure your
for future reference.
gas grill is properly assembled, installed and main-
tained. Failure to follow these instructions could
Manufacturer's Customer Service Ne_pline:
result in serious bodily injury and/or property dam-
if there are damaged or missing parts when you
age.
Resumo do conteúdo contido na página número 2
Warranty ..................................................... 2 Safety Instructions ..................................... 2 Combustion by-products produced when using this product contain chemicals known PreoAssembly Instructions ........................ 4 to the State of California to cause cancer, Hardware, Parts Diagram and Lists...5 birth defects, or other reproductive harm. Assembly Instructions ................................ 9 Lighting Instructions ................................. 16 /
Resumo do conteúdo contido na página número 3
gas grill. Call Sears at 1-800-4-MY-HOME for Proper Placementand Clearanceof Gritl a Sears authorized replacement hose. Neveruseyourgasgrillinagarage, porch, shed, ,, Never light your gas grill with the lid closed breezeway oranyotherenclosed area. Yourgasgrillis tobeusedoutdoorsonly,atleast24inches fromthe or before checking to insure the burner tubes are fully seated over the gas valve orifices. backandside of anycombustible surface. Your ,, Never allow children to operate your grill. Do gasgr
Resumo do conteúdo contido na página número 4
iF,, WARNtNG The location of the burner tube with respect To reducethe chanceof "FLASH-BACK" (see to the orifice is vital for safe operation. CAUTIONon page3) cleanthe burnertubesand Check to ensure the orifice is inside of the burnersbeforefullyassembling yourgrill.Remove burner tube before using your gas grill. See the cotterpin from the rearunderside of each Fig. 2. If the burner tube does not fit over burnerusinga pairof longnosepliers.Carefully the valve orifice, lighting the burner may lif
Resumo do conteúdo contido na página número 5
Thefollowingtableillustrates a breakdown of the hardwarepack.it highlights whatcomponents areused in the variousstagesof assembly. Ref. Component Qty.to Use Purpose of Components H005 1/4"xl/2"PhillipsHeadScrew 4 InstallBottomShelfTo CartLegs H008 1/4"Nut 4 H001 3/8" WheelBolt 2 InstallWheelsTo Cart Legs H002 SpringWasher 2 H003 3/8" Nut 2 InstallRearPanelTo Cart H005 1/4"xl/2"PhillipsHeadScrew 3 H008 1/4"Nut 3 H005 1/4"xl/2"PhillipsHeadScrew 7 InstallTop PanelTo Cart H008 1/4"Nut 7 H005 1,"4"xl
Resumo do conteúdo contido na página número 6
Actual Sizeand Quantity of Each Hardware Piece: f-, \\ i \4 M6 Phittips Head Screw 3/8" Wheel Bolt 3/8" Nut Qty. 2 Qty. 2 Spring Washer Qty. 2 Ref. # H015(packed with Ref. # H001 Qty. 2 Ref. # H002 Ref. # H003 Tool Holder) i' 'i 1/4"x3/4" Phillips 1/4"xl/2" Phillips 1/4"x5/8" Part- M4x6mm Phiitips 1/4" Nut 1/4" Lock Nut Head Screw Head Screw Threaded Bolt Head Screw Qty. 22 Qty. 4 Qty. 8 Qty. 26 (4 for LPG) Qty. 4 Qty. 4 Ref. # H008 Ref. # H009 Ref. # H004 Ref. # H005 Ref. # H006 Ref. # H007 Doo
Resumo do conteúdo contido na página número 7
Remove all components from the packing carton and place within easy reach. Do not throw the shipping carton away; instead use it as an elevated assembly surface. 1 LPG = Liquid Propane Gas 4 NG = Natural Gas 3 6 11 12 13 16 15 26 25 23 21 44 27 48 46 (LPG only) 47 (LPG only) 53 52 ..... 49_ 50 / 29 j56 35J 32 /57 (LPGonly) 41 /58 '\ (LPG only) 34 \ 42 Y J 36 35 Y 59 28 Y 37 31 Y 33 54 30a 55 j 62 4O Y (for LPG) 30b 43 39 (LPGonly) "\\\ _ _ 61 _or NG) 38 60 (LPG only') (NG6o31y) -_
Resumo do conteúdo contido na página número 8
REF# DESCR_PT{ON PART# QTY REF# DESCR{PTION PART# QTY 1, Lid o Stainless Steel P0149F 1 43. Tank Guide (LPG only) P4033B 1 2, Lid Side Panel- Left P0145B 1 44. AA Battery P8080A 1 3, Lid Side Panel- Right P0144B 1 45. Heat°Insulating Spacer P5573A 2 4, Temperature Gauge P0615D 1 46. Fuel Gauge Assembly (LPG only)P80F9B 1 5. Name Plate P0459A 1 47. Fixing Ring (LPG only) P80F9C 1 6. Lid Handle P0237D 1 48. Tool Holder P55B6B 1 P55B6C 2 7. Stainless Steel Cooking Rack P1521B 1 49. Screw Cover P55B
Resumo do conteúdo contido na página número 9
Figure 1 DRAWER CHANNEL Beforeassembling yourgasgrill,usethe parts list to checkthat all necessary partsare included. inspectall partsfor damage as youproceed. Donot assemble or operate yourgrillif it appears damaged. if youhavequestions during theassembly process, call 8am- 8pmCST,Monday throughFriday, 1-888-317-7642 CART LEGS Remove the white PVC protective film from stainless stee{ surfaces before assembly. CAUTION: CASTOR SEAT While it is possible for one person to assemble this gas grill, o
Resumo do conteúdo contido na página número 10
Assembling 1"he Cabinet Doors Figure 4 1. Install Door Stops to Bottom Shelf and Top Panel of Cabinet. See Fig. 4. Secure firmly TOP PANEL using 4 of the 1/4"xl/2" Phillips head screws OF CABINET and nuts. 2. if you haven't already done so, remove the HINGE SIDE white protective film from the stainless steel OF CART LEGS Doors. Attach a Door Handle to each Front Door using 2 of the M4x6mm Phillips head screws provided. See Fig. 8. Be careful not to scratch the door surfaces. 3. When installing t
Resumo do conteúdo contido na página número 11
Figure6 Assernb{ingThe LP Gas Tank Hook Attachthe Pressure CylinderHolderandTank TRACK Guideto the CartLegs-Wheel Sideof grillas FOR PULLED-OUT shownin Fig.6. Alignthe tappedholesof both SPICE TRA_ partswiththe holeson SidePanel.Securefirmly using4 of the 1/4"xl/2"Phillipsheadscrewsand nutsprovided. PRESSURE CYLINDER AssemblingTheGrilm Pulled-outSpiceTray HOLDER 1. install2 of the 1/4"xl/2"Phillipsheadscrews to the rearof the Track.Withoutthesescrews the Pulled-out SpiceTraywill notstopproperly.
Resumo do conteúdo contido na página número 12
Installing Side Burner and Side Shelf Figure 9 STORAGE BIN 1. Remove and discard the protective rubber boots from the Side Shelf and Side Burner braces. 2. Enlisting the aid of an assistant, attach Side Burner to tank side of grill. Remove the fasten- ing strip from burner. Attach Side Shelf to side CONNECTION opposite tank as shown in Fig. 9. Align the 4 TUBE holes on Side Shelf and Side Burner frame with the Cart Legs. Tighten securely using 4 of the IGNITION WIRE FROM SIDE BURNER 1/4"x3/4" Ph
Resumo do conteúdo contido na página número 13
Insta{lingLP Gas Fuem GaugeAssemb{y Figure10a 1. Unscrew the M18x1.5and M8x1.25nutsfrom the Pressure Cylinder. 2. Unscrew and removethe FixingRingfromthe Dial.See Fig. 10a. FIXING RING 3. inserttheend withPressureCylinderthrough the notchedholeon rightSideShelf.See Fig. 10b.Turnthe Dialuntil it matchesthe notchedhole,and pushit intothe hole. FigurelOb 4. Screwthe FixingRingbackto the Dialfrom the PressureCylinderside.See Fig. 10c. 5. insertthe PressureCylinderintoPressure CylinderGuide,and secur
Resumo do conteúdo contido na página número 14
ignitor Battery Installation- See Fig. 12 Figure 12 1. Unscrew the IgnitorCaplocatedon the grin ControlPanelandremovethe Contactand Springfromthe ignitorSlot. 2. Placethe manufacturer suppliedAA battery intothe ignitorSlot. Be sureto placethe IGNITOR SLOT positivepolefacingtowardyou. . Place the Spring over the AA battery, then place the Contact on top of the Spring. Screw the ignitor Cap back onto the grill Control Panel. IGNITOR CAP _,, Electrode Check - Requires an Assistant AA BATTERY Before
Resumo do conteúdo contido na página número 15
InstallingCookingComponents Figure14 important:Beforecooking on yourgrillthefirst time,washthe cooking gridsandcooking rack withwarm,soapywater.Rinseand drythoroughly. SECONDARY COOKING RACK Seasonwithcookingoil regularly. Aftercookingis "-,\ \ completed, turngrillto HIGHsettingfor aboutfive \4 minutesto burnoff excessgreaseor foodresidue. CAST iRON _ COOKING GRID \ 1. Placethe2 Stainless SteelFlameTamerson thelowerledgeaboveburners. SeeFig. 14. Theyshouldmeetin the center. STAINLESS STEEL FLAME
Resumo do conteúdo contido na página número 16
z. WARNING WARNING Failure to open Grill or Side Burner Lid A strong gas smell, or the hissing sound of during the lighting procedures could gas indicates a serious problem with your gas result in a fire or explosion that could grill or the LP gas tank. Failure to immedi- cause serious bodily injury, death, or ately follow the steps listed below could result property damage. in a fire or explosion that could cause seri- ous bodily injury, death, or property dam- . age. Set control knobs to OFF a
Resumo do conteúdo contido na página número 17
. if the gdH still does not light you may need if thegrill fallsto light propeNy: to purge air from the gas line or reset the 1. Turngasoffatsourceandturnthecontrol knobto regulator excess gas flow device. Note: This OFF.Waitatleastfiveminutes forgastoclear, procedure should be done every time a new thenretry. LP gas tank is connected to your grill. 2. Checkgassupplyandconnections. To purge air from your gas line and/or 3. Repeatlightingprocedure. If yourgrillstillfails reset the regulator exces
Resumo do conteúdo contido na página número 18
8. Check each spark electrode, adjusting as needed. The space between the Spark Electrode Tip and Spark Receiver should be approximately 3/16". Aswithallappliances, propercareandmaintenance willkeepyourgrillintopoperating condition and 9. Replace the burners and adjust the gas collector prolong itslife.Byfollowing thesecleaning procedures box. The edge of the collector box should be onatimelybasis, yourgrillwillstaycleanandwork overlapping the burner port. properlywith minimum effort. 10. Replac
Resumo do conteúdo contido na página número 19
Regardless ofwhich burner cleaning procedure you CleaningThe BurnerTubesandBurnerPorts use,werecommend youalsocomplete thefollowing Toreduce thechance of"FLASH=BACK" theproce= stepstohelpprolong burner life. durebelow should befollowed atleastonceamonth in 1. Useawirebrushtoclean theentireoutersurface latesummer orearlyfallwhenspiders aremostactive ofeachburner untilfreeoffoodresidue anddirt. orwhenyourgrillhasnotbeenusedforaperiod of time. 2. Clean anyclogged portswitha stiffwire,suchas anopenp
Resumo do conteúdo contido na página número 20
Question: Howdo Iseason Castiron? Answer:Before andaftereachcookout, apply athin layer ofcooking oil,spray orvegetable shortening to Question:CanIconvert myKenmore gasgrillfrom eachCooking Gridandoptional cast-iron accessory. Be onefueltypetoanother? suretocoattheentire surface including edges andany Answer: Your Kenmore gasgrillismanufactured to areas withchipped porcelain. Insert theCooking Grids exact specifications andisapproved bytheCanadian andaccessories intoyourgrillandwarm2to3minutes. S
