Manual do usuário Bakers Pride Oven Self Service Hot Food Merchandiser MODEL MHC4/8

Resumo do conteúdo contido na página número 1

Operating Instructions

MODEL MHC4/8

Self Service Hot Food Merchandiser


1
NOTICE:
THE COMBINATION OF FACTS, DATA, DESIGN ELEMENTS, ENGINEERING DATA, MANUFACTURING DATA & ASSEMBLY DATA
WHICH MAY BE CONTAINED IN THIS DOCUMENT ARE OF A PROPRIETARY NATURE TO BKI.
THESE MATERIALS ARE NOT TO BE USED OR COPIED WITHOUT PRIOR WRITTEN PERMISSION FROM BKI.
ALL RIGHTS ARE RESERVED.

Resumo do conteúdo contido na página número 2

INTRODUCTION GENERAL Your hot food deli case has been completely assembled and tested before despatch. Any accessories may have been supplied or packed separately, check all parts and accessories against the delivery note. Ensure that all packaging has been removed before switching on. Installation Due to the open fronted design, the maximum holding time for the product to be held will depend on the siting of the cabinet in store. Ideally the cabinet should not be sited by

Resumo do conteúdo contido na página número 3

OPERATING INSTRUCTIONS NOTE: To ensure your Hot Case operates at the correct temperature, the controls are set to ambient conditions for the cabinet to operate and maintain a minimum product o internal temperature of 65 C . Remember a digital thermometer should be used to read the internal temperature of each food product, check the food temperatures hourly and record on product temperature sheets. PREHEATING Ensure shelves are clean before switching the

Resumo do conteúdo contido na página número 4

PLACING PRODUCT INTO THE CABINET In order to maintain a satisfactory product internal temperature and achieve a 2 hour holding time, o o cook products to Minimum 85 C Maximum 90 C, package quickly to minimise temperature loss & place directly into multi-deck merchandiser. Do not over-cook or overheat food items that are to be held hot, over-cooking will result in excessive moisture loss that will reduce holding times. Do not package and display products from another hot cabinet i

Resumo do conteúdo contido na página número 5

CLEANING NOTICE: THIS CABINET SHOULD BE CLEANED AT THE END OF EACH WORKING DAY 1. Remove Bagged products to sale or waste. o 2. Turn the cabinet “OFF” and allow to cool below 50 C (Hand Hot). 3. Wipe shelves clean with a soft cloth and solution of Antibacterial detergent and warm water. Note: Do Not Remove Shelves 4. Wipe down Interior and exterior cabinet surfaces (Except glass end panels) with Antibacterial detergent solution.

Resumo do conteúdo contido na página número 6

PREVENTATIVE MAINTENANCE 1. Read and understand the Operating Instructions. 2. Clean the unit each day. 3. Refer to the troubleshooting guide if the unit does not operate properly. 4. Have only an authorised serviceman check and repair unit when needed. TROUBLE – SHOOTING PROBLEM CORRECTIVE ACTION Unit fails to operate 1. No Power 1. Assure that power is sound 2.Circuit breaker is off 2. Reset circuit breaker No Heat 1. Defective