Краткое содержание страницы № 1
®
3627336241
Operation and
Maintenance Manual
DC POWERED
SCREW DRIVE
OPENER
Cpetelmo htwi N i C telli D o e®
t leba of Co Nte Nt S
Warranty Information . . . . . . . . . . . . .2 . . . . . .
Remote Co Nt Rol a ND SeRieS ii
Safety Information . . . . . . . . . . . . . . .3 . . . . . . .
e el Ct Ro Ni CS
Important Installation Instructions . . . . . . 3 .
For 7’ 6” Doors. Extension Kit is available for 8’ Doors
Included Wall Console MUST be installed prior to Operation
Safety Features
Краткое содержание страницы № 2
t eh Ge Nie Compa Ny l mitei D w a RRa Nty Please note the following information,so it is available if you What is covered? need to call us. Any defect in material and product workmanship from personal, normal house- hold use in accordance with the Owner’s Manual . Date Purchased __________/_________/__________ For how long? Serial Number* ______________________________ MODEL 4560 . . . Lifetime* on motor and 5 years all other parts . Operator Model* _______________
Краткое содержание страницы № 3
oVeRView of N pote tial Z ha RDS a Overhead doors are large, heavy objects that move with the help of springs under high tension and electric motors . Since moving objects, springs under tension, and electric motors can cause injuries, your safety and the safety of others depend on you r eading the i nformation in this manual . If you have questions or do not understand the information presented, call The Genie Company . or your local Genie Distributor . In this section, and those tha
Краткое содержание страницы № 4
KEEP FEET CLEAR OF DOOR p Re -i NStaolatil N Ceh Ckli St This Opener includes parts and supplies needed to install in most garages and connect to most garage doors . There are many variations of garages and garage doors . A few additional parts and supplies may be needed to install Opener into your garage and connect to your 3’ - 4’ 3’ - 4’ garage door . While checking items listed below, note any additional One-Piece Sectional items you will need . Door Door Tools used in this secti
Краткое содержание страницы № 5
(7’-6” door) Perforated Straps FINISHED CEILINGS NOTE Locate ceiling joists or trusses using • For all types and styles of doors: a stud finder or similar device . – If the ceiling in your garage is so low that there is not at least a 3” space above the Header Bracket Attach angle iron(not included) to mounting point, contact a Genie Factory joists or trusses through finish material using Lag Screws . Authorized Dealer . • If a door spring is
Краткое содержание страницы № 6
Re Cmmeo NDe D tool S IMPORTANT Check Step 8: SAFETY INSTRUCTIONS A Tools (Figure 8): B Additional tools to make installation easier: WARNING: • Slotted and phillips screw-driver bits • Stud finder • Sheet-metal cutting snips TO REDUCE THE RISK OF SEVERE INJURY OR DEATH D Roem Ve e ix Sit NG Ga Ra Ge Check Step 9: 1 READ AND FOLLOW ALL INSTRUCTIONS . Doo R l o Ck S 2 Never let children operate or play with the Door Controls . Keep th
Краткое содержание страницы № 7
m ai Nte Na NCe a ND a Dju Stme Nt S NOTE a Duj Sti NG l imit Stiw Ceh S Adjustment 1: • Little effort is required to turn the Force a ND f o RCe Co Nt Rol S Adjusting Knobs . • If the door stops moving while opening or closing, adjust the Open Force or Close Force Controls WARNING slightly clockwise (to slightly increase the force) and retry the step . • A moving garage door can cause serious injury • The Open Fo
Краткое содержание страницы № 8
a CCe SSo Rei S Setti NG Co Nat Ct Re Ve RSe Adjustment 2: f u NCtio N C p Ro GRamim NG eht Programming 1: Rteemo Co Nt Rlo S NOTE Limit Switch and Force Adjustments must be completed NOTE before checking the contact reverse function (Figure A-3) . A Open garage door using Wall Console . • Each Remote Control must be programmed B Lay a 2” x 4” board flat in center of doorway . separately . C Close door using Wall Console . •
Краткое содержание страницы № 9
Remote Control Operation i NSllat l i Gth b lbu S a ND l e NS A Press Button on Remote Control . Garage door will move . B Press Button again . Garage door will stop: • The door automatically stops at the end of the open or Snap Lens Hinges into close cycle . slots on back of Motor Cover C Press Button again . Garage door will reverse . 60 Watts maximum Push in Lens Latches 1A to close Lens 1 Button Compact Remote 3 Button Compact Remote Figure MA-4 Install Lens Cover and Ligh
Краткое содержание страницы № 10
MAINTENANCE WARNING A Monthly: • Door springs and door hardware: If the door fails to reverse on contact with the board, – Oil door roller, bearings, and hinges using silicone adjust the Close Force Control as specified in Set Limit lubricant or light oil . Switches and Force Controls on page 7 . If the Opener still fails, contact a Genie Factory Authorized Dealer for service or call Customer Service at 1-800-35-GENIE . WAR
Краткое содержание страницы № 11
Opener System Self-Diagnostic Troubleshooting • See Status Light on Figure MA-2, page 9) You See Problem What to Do Reference 1 BLINK, Motor Drive • Reset Opener—unplug (or disconnect power), wait 5 seconds, plug Pause Board back in (reapply power), and activate from Wall Console . (Repeat) Interrupt Normal • First Cycle will run at slow speed . operation restored If the problem • Check door condition . NOTE: This Opener is equipped with an See Door
Краткое содержание страницы № 12
General Troubleshooting (Always Check the Status LED Light) Problem What To Do Opener does not run 1 . Check power source . from Remote Control A . If Opener is connected to an outlet: Plug a working lamp into outlet used for Power Head . • If lamp glows, power source and outlet are OK . • If not, check fuse or circuit breaker or non-compatible GFCI . • NOTE: A licensed electrician must replace non-compatible GFCI’s.
Краткое содержание страницы № 13
General Troubleshooting (Always Check the Status LED Light)(Continued) Problem What To Do Remote Control has less Relocate Remote Control inside car . • than 25’ operating range Ensure Remote Control is pointing toward garage door when pressing Control Button . • Replace Remote Control Battery (See page 9) . • Reposition Opener Antenna Wire . • Do Not attempt to retune Remote Controls or Receiver . • Opener works from Wall Program
Краткое содержание страницы № 14
p oew R h ae D a SSbylme e xplo De D Vwie Parts List Item Part Name Quantity [ ] 1 Item Part Name Required 1 Power Head Assembly (main carton) 1 2 1/4”-20 x 13/16” Hex Head Shoulder Bolt (blue bag) 2 (yellow shoulder bolt) 4 Rail Assembly, 3 piece (main carton) 1 4A First Rail Section (main carton) 1 4B Middle Rail Section (main carton) 1 4C End Rail Section (main carton) 1 8 1/4”-20
Краткое содержание страницы № 15
h a RDwa Re e polx De D Veiw NOTE Opener will not function unless Safe-T-Beam® System is installed and Force Controls are properly set . For Help, call 1-800-35-GENIE or visit www.geniecompany.com 15
Краткое содержание страницы № 16
® Garage Door Opener Accessories Order Form Ordering Instructions Formulario de pedido de accesorios para abridores de puertas de garaje No C .O .D . shipments . Please include check or money Formulaire de commande des accessoires pour ouvre-porte de garage order, made payable to The Genie Company . Do not send For additional accessories not shown . visit our website at www .geniecompany .com cash . Allow 3-4 weeks for delivery . Para accesorios adicionalesno mostrada, visite nuestro sitio
