Inhaltszusammenfassung zur Seite Nr. 1
JENN-AIR
Use and Care Manual
Pro-Style °Gas Grill
Model JGD8348, CVG4380P
_ Range Cookto_
l
Printedin U.S.A. Cat. No. CA4380UE
©1996 Jenn-Air Part No. 8111P197-60 6/96
Inhaltszusammenfassung zur Seite Nr. 2
WARNING: If the information in this manual is not followed exactly, a fire or explosion may re- sult causing property damage, personal injury or death. - Do not store or use gasoline or other flam- mable vapors and liquids in the vicinity of this or any other appliance. - WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Donottouch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's
Inhaltszusammenfassung zur Seite Nr. 3
Read before operating your cooktop All appliances - regardless of the manufacturer - have the potential through improperor careless use to create safety problems. Therefore the followingsafety precautionsshould be observed: 1. Besureyourapplianceis properlyinstalledandgroundedbya qualified technician. 2. Neveruseyourapplianceforwarmingorheatingthe room,Thiswarning isbasedonsafetyconsiderations. 3. Childrenshouldnot be leftaloneor unattendedin area whereapplianceis in use. They should never be al
Inhaltszusammenfassung zur Seite Nr. 4
13. CAUTION- Do not store items of interest to children in cabinets above cooktop-childrenclimbingonthe cooktopto reach itemscouldbeseriously injured. 14. Donot touchgrill and surfaceburnerareas, areas near burners,or metal landingspace. Duringand after use, these areas may be hot enough to causeburns. Avoidcontactwiththeseareasbyclothingorotherflammable materialsuntil they have had sufficienttime to cool. 15. Do not heat unopenedfood containers. Buildup of pressure may cause containerto burst a
Inhaltszusammenfassung zur Seite Nr. 5
Important Safety Notice and Warning The CaliforniaSafe DrinkingWater andToxic EnforcementAct of 1986 (Propo- sition 65) requires the Governor of California to publisha list of substances known to the State of California to cause cancer or reproductive harm, and requires businesses to warn customers of potential exposures to such sub- stances. Users ofthis appliance are hereby warned that burning of gas can result in low- level exposure to some of the listed substances, including benzene, formald
Inhaltszusammenfassung zur Seite Nr. 6
The built-in ventilation system removes cooking vapors, odors and smoke from foods prepared on the cooktop, grill and grill accessories. Regular use of this system will insure a more comfortable and less humid kitchen which is free of heavy cooking odors and fumes that normally create a frequent need for clean- ing and redecorating. • To operate the ventilation system manually, turn fan knob clockwise to ON position, ummuuli ......... _ • The ventilation system will operate automatically _ _---.
Inhaltszusammenfassung zur Seite Nr. 7
l Size of Cookware 1 To achieve optimumcockingperformance usecookpotswithflatbottomsand tightfitting covers. Flame size should be adjusted so it does not extend beyond the edge of the cookware. This instructionis basedon safetyconsiderations. Adjustingthe size of the flame to fitthe size of the ccokware also helpsto save fuel. Important: Leave a minimumof 11/2"between side of pan and surroundingsurfaces, such as countertop backsplashor side walls, to allow heat to escape to avoid possible damage
Inhaltszusammenfassung zur Seite Nr. 8
Yournewcooktopburnershavebeenpresetfor an"average"setof conditions.Regional variancesin gaspressureand atmosphericconditionssuch as height abovesea level mayaffect your initialflame performance. Whenthe controlknob isturned ON,gasentersthe mixertube and mixeswithair. This airand gasmixtureflowsto the burnerhead and is lightedbya sparkfromthe solidstate igniter. A properlyadjustedburnerwith clean ports will light within a few seconds. The cone- shapedflamewill be clear blue incolorwith a clearly
Inhaltszusammenfassung zur Seite Nr. 9
To adjust grill burner air shutters and surface burner air shutters (Some models): The left hand air shutter controls the rear half of the grill burner or the rear surface burner. The right hand shutter controls the front half of the grill burner or the front sur- face burner. Slide air shutter backward or forward to in- crease or decrease the size of the air open- AIRSHU'CIER ing. screwdriver blade may be required to make Air shutters fit snugly on the burner, so a x.__;_ this adjustment. Obser
Inhaltszusammenfassung zur Seite Nr. 10
To Set Controls I • Since the controls are a push-turn type, they must be pushed in before turning. To set (from the OFF position), push in on control knob and immediately turn counter- clockwise to the MTE position until burner ignites. After ignition, turn knob clockwise to desired setting. • Igniter will continue to spark until knob is turned clockwise back to or past Hi position on knob. 1. 2. FAN 3. 4. 5. 6. 1. Left rear surface burner or grill. Note: When using an AG202 surface 2. Left fro
Inhaltszusammenfassung zur Seite Nr. 11
1. Be sure control knobs are turned OFF. 2. If the grill burner and grill grates are in place, remove before installing a surface burner module. Clean burner basin of any grease accumulation. (See page 18 for cleaning recommendations.) 3,. Position the burner assembly with the mixer tube openings toward the orifices. Slide the burner assembly toward the orifices until opening for igniter is over the igniter. Lower into place until side openings are resting on the burner supports and igniter is c
Inhaltszusammenfassung zur Seite Nr. 12
The grill consistsof two blackgrill gratesand a grill burner. Only installthe grill on the leftside of your cooktop. 1, Before installinggrill components,be certain controlknobs are in the OFF position. 2. Position thegrillburnerwithmixertubeopenings towardtheorifices.Slidethe burner towardsthe orificesuntilthe igniteris in betweenfront and rear grill sections.Lowerintoplaceuntilsideopeningsarerestingon theburnersupport pins. 3. Placethegrillgrateson thetopof thecooktop. NOTE: Beforeusingthe gri
Inhaltszusammenfassung zur Seite Nr. 13
I Using the Grill J • Before the first use, washyour new grill gratesin hot soapy water, rinse and dry. Then "season"the surface by wiping on a thin coating of cooking oil. Remove excess oil by wiping again with another paper towel. This procedureshould be repeatedwhen: a) cleaning in the dishwashersince the detergentmay remove seasoning,or b)anytimea sugar-basedmarinade(forexample,barbecuesauce)is goingto be used. • Use nonmetallicspatulasor utensilsto prevent damagingthe Excalibur®nonstick gri
Inhaltszusammenfassung zur Seite Nr. 14
r IGrill Guide Preheat grillon Hi, 5 minutes,for best flavor Type . . ; _;r"-- :__ :e Setting CookingTime..:'_-_ Procedure. . Steak(1/2 :_/4") ° = _" = _ • _:!Rare • ; _ i: _;;:Hi_ "t 6to't0 min_e_ •:. Well _-:,--_-.._--_ - ---_, ,,-,._:Bl :..... _"_ .we,-'__ _:'_ _;_:_!_ :: -_'_ _%___' /i_;i. i;_i_i :'_" Hamburgers_;_Oz 3-4 .}-_';-_T!TAed_20°t625 mi_" Fish " : ::' Small,Whole(1") ! Med 15to20 minutes Brushwithbutter. Turnafterhalf Shrimp •Med 10to 20minUteS_ ::_Tum andbrushwithbutteror :: (skew
Inhaltszusammenfassung zur Seite Nr. 15
IGri!ling TiPs l With your Jenn-Air, grill literally any food you've considered "at its best" when prepared outdoors can now be prepared indoors with less fuss and great flavor. The following suggestions are good rules to follow and will increase your enjoyment of the equipment. • Be sure to follow directions on page 13 for using the grill. • Suggested cooking times and control settings are approximate due to variations in meats. Experience will quickly indicate cooking times as well as which se
Inhaltszusammenfassung zur Seite Nr. 16
The knobson the controlpanel can be removedwiththe contro]sinthe OFF position. Pull each knob straight from the shaft. Wash knobs in warm soapy water or dishwasher; do not use abrasive cJeansersor materials. To replace each knob, match flat part of knob opening with the flat of the shaft, returning in OFF position. Important: Never use a metal blade to pry knob off. Be sure the grill is cool and controls are OFF. These are made from cast aluminum and are coated with the Excalibur_ nonstick finis
Inhaltszusammenfassung zur Seite Nr. 17
[Surface Burner Assembly] To clean thesurface burnerassembly (surface burnergrates, aerationtray, and surface burners). • Lightsoil - wash in hot soapy water, rinse and dry. • Moderate soil - use Comet, BonAmi, a soft scrubcleanser or plastic puff. • Heavy soil - for occasional use only, use oven cleaner followingmanufacturer's directions. NOTE: • The porcelain enamel used on your cooktop is acid resistant, not acid proof. Therefore, acid foods (such as vinegar, tomato, milk, etc.) spilled on th
Inhaltszusammenfassung zur Seite Nr. 18
JIgnitersI • Itisimportanttokeepigniterportopeningsonburnersclearandfreeofobstructions to avoid ignitionfailure and possiblegas buildup. If the port openingsare blocked, use a toothpickto remove food particles. • The igniter cap and stem can be cleaned with warm soapy water and a plastic scrubber. The wire electrode inside the cap can be cleaned with a small brush. Rinse and dry. This area is located under the grill and surface burners and should be cleaned after each use of the grill. • To remo
Inhaltszusammenfassung zur Seite Nr. 19
Jenn-Air's ventilation system is designed to capture both cooking fumes and smoke while grilling. If the system does not, these are some ducting installation situations to check: • 6" diameter round or 31/4 ' x 10" rectangular ducting should be used for duct lengths 10'-60'. Note: 5" diameter round ducUng must be used if the duct length is 10' or less. • No morethan three 900elbowsshouldbe used. Distancebetween elbows should be at least 18". • Recommended Jenn-Air wallcap shouldbe used. Make sur
Inhaltszusammenfassung zur Seite Nr. 20
Check the following list to be sure a service call is really necessary. If grill or surface burner fails to light: • check to be sure unit is properlyconnectedto power supply, • check for a blowncircuit fuse or a tripped maincircuit breaker. • check to be sure burneris correctly rated for your type of gas. • check to be sure burnerports or ignition ports are not clogged. • check to be sure igniteris clicking. If igniter doesn'tclick, turn control knob off. • check to be sure regulator is set for
