Summary of the content on the page No. 1
LP GAS GRILL OWNER'S MANUAL
# 3200 & 5200
GUÍA DEL PROPIETARIO DEL ASADOR DE GAS LICUADO DE PROPANO - PG 24
GUIDE DE L’UTILISATEUR DU GRILL À GAZ PL - PG 39
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE - PG 3
#20208550 Customer Service: 1-800-382-2637
NOTICE TO INSTALLER: These instructions
YOU MUST READ THIS OWNER’S GUIDE
must be left with the owner and the owner
BEFORE OPERATING YOUR GAS GRILL
should keep them for future use.
DANGER
THIS GAS APPLIANCE IS DESIGNED FOR
If you smell gas:
OUTDOOR USE O
Summary of the content on the page No. 2
DANGERS AND W DANGERS AND WARNINGS ARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNING Do not lift the barbecue using the control panel as a handle. Lifting by the control panel can damage gas handling and electrical components. Damage to gas handling and electrical components can result in serious bodily injury or death and damag
Summary of the content on the page No. 3
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE CAUTION: Although we make every effort to ensure that the assembly process is as easy and as safe as possible, it is inher- ent with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful while handling any parts during assembly. It is strongly recommended that hands be protected with a pair of work gloves. WARNING: Care must be taken to ensure that this gr
Summary of the content on the page No. 4
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE TOOLS NEEDED: HERRAMIENTAS REQUERIDAS: OUTILS NECESSAIRES: 11mm (7/16”) 3 BRNR. 5 BRNR. 3 BRNR. 5 BRNR. 0 1 1 1 0 1 1 1 1 1 2 3 4 4 3 5 4 4 2 6 1 1 2 6 1 1 3 3 4 www.ducane.com
Summary of the content on the page No. 5
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 2 - 1 - 2 - 1 - 1 NOTE: The two (2) lower bolts used to install the stainless steel side shelf (s) are CAUTION: Failure to install the Side Burner properly could threaded into the grill cart on the both sides of the grill. Remove the bolts and re- install when attaching the stainless steel side shelf (s). cause the unit to loosen and fall, causing bodily harm. NOTA: los dos (2) pernos inferiores para instalar el (los) anaquel
Summary of the content on the page No. 6
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 2 View from underneath Vista desde abajo Vue du dessous (1) (2) WARNING: The side burner orifice (1) must be parallel to the side burner tube opening (2). ADVERTENCIA: El orificio (1) del quemador lateral debe de estar paralelo a la abertura (2) del tubo del quemador lateral. AVERTISSEMENT: L’orifice du brûleur latéral (1) doit être parallèle à l’ouverture du tube du brûleur latéral (2). 6 www.ducane.com
Summary of the content on the page No. 7
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 2 - 1 - 2 - 1 - 3 3 - 4 5 7
Summary of the content on the page No. 8
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 6 5 4 - 4 - 7 BRNR. 8 www.ducane.com
Summary of the content on the page No. 9
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 3 5 8 8 BRNR. BRNR. 5 9 BRNR. 9
Summary of the content on the page No. 10
W WARRANTY ARRANTY, GARANTÍA, GARANTIE , GARANTÍA, GARANTIE This Limited Warranty does not cover failures or operating diffi culties due to accident, abuse, misuse, ® alteration, misapplication, vandalism, improper installation, use in a commercial enterprise, improper Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane Stain- less Series gas grill that it will be free of defects in material and workmanship from the date of maintenance, including but not limited to dam
Summary of the content on the page No. 11
SAFETY INFORMATION IMPORTANTWe urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation ® of your new Ducane Gas Grill. We also advise you to keep this manual for future reference. WARNING: Keep any electrical supply cord and the fuel WARNING: Your grill has been designed to operate using supply hose away from any heated surfaces. only the gas specified on the rating plate. Do not attempt
Summary of the content on the page No. 12
CONNECTION CONNECTION Liquid Propane Gas Grills Liquid Propane Gas Grills Type of Gas Handling Liquid Propane Gas Propane gas should be handled and stored with care. We suggest asking your propane � Your LP grill is factory built to operate using liquid propane only. Never attempt to gas dealer, when having your tank fi lled, for a short course in handling, care and operate your grill on gases other than the type specifi ed on the grill rating plate. � The regulator supplied with your liquid p
Summary of the content on the page No. 13
CONNECTION CONNECTION Liquid Propane Gas Grills Liquid Propane Gas Grills The propane cylinder valve connection provided with this grill incorporates the four Excess Flow Control important safeguards listed: The propane regulator assembly incorporates a fl ow limiting device designed to supply Hand Assembly the grill with suffi cient gas fl ow, yet control any excess fl ow. 1. Make sure the cylinder valve and all appliance valves are in their “OFF” positions. Rapid changes in pressure can trigger
Summary of the content on the page No. 14
NORMAL OPERA NORMAL OPERATION TION DANGER: Make sure that the lid is in the full open postion Breaking in Your Grill any time you attempt to light your grill. Failure to open the When fi ring your grill for the fi rst time, it is advisable to run the Main Burner(s) on “HI” for 20 minutes with the hood down and then turn the Main Burners “OFF”. This lid could lead to delayed ignition which may result in serious tempers the grill. bodily injury or death, or in a fire or an explosion causing
Summary of the content on the page No. 15
N NORMAL OPERA ORMAL OPERATION TION high-temperature areas. Therefore, use good judgment and Preheating Grill It is extremely important that your grill be up to temperature before you begin using a certain degree of caution when grilling on this product. We it. After lighting, close the lid and preheat the grill on “high” for 10 minutes. This suggest a covered, protected hand during operation of grill. preheating will ensure that the cooking grid is hot enough for proper grilling. Do not mo
Summary of the content on the page No. 16
NORMAL OPERA NORMAL OPERATION TION Match Lighting Your Grill Main Burners Follow the simple steps listed below to match light the Main Burner(s) of grill, in the event snap ignition fails: 1 4 WARNING: (Make sure that 5 minutes have elapsed since last attempt of lighting.) Make sure that the lid is in the full open position any time you attempt to light your grill. Failure to open the lid could lead to delayed ignition which may result in serious bodily injury or death, or in a fire or an
Summary of the content on the page No. 17
2 1 5 4 3 1 5 N NORMAL OPERA ORMAL OPERATION TION Side Burner Ignition Follow the simple steps listed below to light the Side Burner (SB) of your grill: DANGER: Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in a explosive flame-up which can cause bodily injury or death. 1. Open the lids and check that the side burner valve is turned off (Push control knob in and turn clockwise to ensu
Summary of the content on the page No. 18
HELPFUL HINTS HELPFUL HINTS Flare Ups Any time you cook fatty foods over an open fl ame, you can expect fl are ups. Flare ups are caused by the fl ash which occurs when the natural juices fall on the heat distribu- tion plates. Controlled fl are ups give foods their delicious outdoor fl avor and appear- ance. Excessive fl are ups may occur when your grill is not level or when cooking fatty foods such as spare ribs and chicken parts, especially if the cooking temperature is set too high. These fl are
Summary of the content on the page No. 19
T TROUBLESHOOTING ROUBLESHOOTING PROBLEM CHECK and CURE IMPORTANT IGNITION SYSTEM Be sure that there is gas fl ow to the burners by attempting to match light your burners. If match lighting is successful, the problem lies somewhere in the ignition system and will need to be checked. MAIN GRILLING BURNERS If the main burner(s) still fails to ignite, make sure that there is gas fl owing to the burner(s) by CAUTION: Always turn the gas supply off at the tank before attempting to match light th
Summary of the content on the page No. 20
MAINTENANCE MAINTENANCE Yes, you paid a lot of money for your grill, but even an expensive grill doesn’t clean IMPORTANT and maintain itself, and you want it to look good and function properly. That’s why � Keep appliance area clear and free from combustible materials, gasoline and other this section of your manual is so important. This section gives you the information fl ammable vapors and liquids at all times. necessary to help you keep your grill looking new and working properly. Reading
