Summary of the content on the page No. 1
LP GAS GRILL OWNER'S MANUAL
GUÍA DEL PROPIETARIO DEL ASADOR DE GAS LICUADO DE PROPANO - PG 24
GUIDE DE L’UTILISATEUR DU GRILL À GAZ PL - PG 41
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE - PG 3
#20529916 Customer Service: 1-800-382-2637
NOTICE TO INSTALLER: These instructions
YOU MUST READ THIS OWNER’S GUIDE
must be left with the owner and the owner
BEFORE OPERATING YOUR GAS GRILL
should keep them for future use.
DANGER
THIS GAS APPLIANCE IS DESIGNED FOR
If you smell gas:
OUTDOOR USE ONLY.
1. Shut o
Summary of the content on the page No. 2
DANGERS AND W DANGERS AND WARNINGS ARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNING Do not lift the barbecue using the control panel as a handle. Lifting by the control panel can damage gas handling and electrical components. Damage to gas handling and electrical components can result in serious bodily injury or death and damag
Summary of the content on the page No. 3
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE CAUTION: Although we make every effort to ensure that the assembly process is as easy and as safe as possible, it is inherent with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful while handling any parts during assembly. IT IS STRONGLY RECOMMENDED THAT HANDS BE PROTECTED WITH A PAIR OF WORK GLOVES. WARNING: Care must be taken to ensure that this gri
Summary of the content on the page No. 4
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 3 BRNR. 5 BRNR. 3 BRNR. 5 BRNR. 1 1 1 2 1 1 1 2 2 1 1 1 1 1 1 8 8 1 1 2 2 1 1 10 10 1 2 2 1 2 2 4 www.ducane.com
Summary of the content on the page No. 5
A ASSEMBL SSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 1 CAUTION: Always remove the warming rack when using the rotisserie. OBSERVACIÓN: Siempre quite la rejilla de calentamiento cuando esté usando el sistema rotativo. REMARQUE: Enlevez toujours la grille de chauffage lors de l’utilisation de la rôtisserie. 2 5
Summary of the content on the page No. 6
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 3 4 NOTE: The bolts to install the WARNING: The rotisserie motor must be stainless steel side shelf are 5 threaded into the grill cart on the right stored indoors when not in use. DO NOT leave it BRNR. side of the grill. Remove the bolts and re-install when mounted to the grill. attaching the stainless steel side shelf. OBSERVACIÓN: Los tornillos utilizados para armar las mesas de PRECAUCIÓN: El motor deber ser almacena
Summary of the content on the page No. 7
ASSEMBL ASSEMBLY Y,, ENSAMBLAJE, ASSEMBLAGE ENSAMBLAJE, ASSEMBLAGE 3 5 6 6 BRNR. BRNR. 3 5 7 7 BRNR. BRNR. 5 8 9 BRNR. 7
Summary of the content on the page No. 8
W WARRANTY ARRANTY, GARANTÍA, GARANTIE , GARANTÍA, GARANTIE This Limited Warranty does not cover failures or operating diffi culties due to accident, abuse, misuse, ® alteration, misapplication, vandalism, improper installation, use in a commercial enterprise, improper Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane Stain- less Series gas grill that it will be free of defects in material and workmanship from the date of maintenance, including but not limited to dam
Summary of the content on the page No. 9
SAFETY INFORMATION IMPORTANT We urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation of your new ® Ducane Gas Grill. We also advise you to keep this manual for future reference. WARNING: Your grill has been designed to operate using WARNING: Do not store a spare LP-gas cylinder under or only the gas specified on the rating plate. Do not attempt near this appliance; Never fill the cyli
Summary of the content on the page No. 10
CONNECTION CONNECTION Liquid Propane Gas Grills Liquid Propane Gas Grills Handling Liquid Propane Gas Type of Gas � Your LP grill is factory built to operate using liquid propane only. Never attempt to Propane gas should be handled and stored with care. We suggest asking your propane operate your grill on gases other than the type specifi ed on the grill rating plate. gas dealer, when having your tank fi lled, for a short course in handling, care and storage of propane gas tanks. Most dealers
Summary of the content on the page No. 11
C CONNECTION ONNECTION L Liquid Propane Gas Grills iquid Propane Gas Grills To ensure that this does not cause diffi culty in lighting the grill, follow these WARNING: Do not use a tool to tighten the connection. instructions 1. Make sure all burner valves are OFF. Using a tool could damage the regulator coupling and could 2. Open cylinder valve and wait 5 seconds. cause a leak resulting in serious bodily injury or death, or in 3. Follow lighting instructions. a fire or an explosion causi
Summary of the content on the page No. 12
NORMAL OPERA NORMAL OPERATION TION ® WARNING: The burner control knobs must be in the OFF WARNING: Your Ducane grill was not designed to operate position before turning on the liquid propane cylinder tank with the Rotisserie Burner and the Main Burner(s) on at valve. If they are not in the OFF position, when you turn the same time. Failure to follow this warning will lead on the LP cylinder valve, the “excess gas flow control” to an overheating condition which would damage grill feat
Summary of the content on the page No. 13
N R U T O T H S U P NORMAL OPERA NORMAL OPERATION TION high-temperature areas. Therefore, use good judgment and Preheating Grill It is extremely important that your grill be up to temperature before you begin using a certain degree of caution when grilling on this product. We it. After lighting, close the lid and preheat the grill on “high” for 10 minutes. This suggest a covered, protected hand during operation of grill. preheating will ensure that the cooking grid is hot enough for pro
Summary of the content on the page No. 14
NORMAL OPERA NORMAL OPERATION TION Match Lighting Your Grill Main Burners Follow the simple steps listed below to match light the Main Burner(s) of grill, in the event snap ignition fails: WARNING: (Make sure that 5 minutes have elapsed since last attempt of lighting.) Make sure that the lid is in the full open position any time you attempt to light your grill. Failure to open the lid could lead to delayed ignition which may result in serious bodily injury or death, or in a fire or an exp
Summary of the content on the page No. 15
N R U T O T H S U P N NORMAL OPERA ORMAL OPERATION TION Side Burner Snap Ignition Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner OFF / ARRÊTÉ / APAGADO lighting tube. You generate the energy for the spark by pushing in the control knob and turning to “START/HI”. This will ignite each individual burner. 1 4 Follow the simple steps listed below to light the Side Burner (SB) of your grill: DANGER: Failure to open the lid while igniting the side
Summary of the content on the page No. 16
N R U T O T H S U P NORMAL OPERA NORMAL OPERATION TION Rotisserie Burner Electronic Ignition Follow the simple steps listed below to light the Rotisserie Burner of your grill: OFF / ARRÊTÉ / APAGADO DANGER: Failure to open the lid while igniting the Rotisserie 1 6 Burner, or not waiting 5 minutes to allow the gas to clear if the Rotisserie Burner does not light, may result in a explosive flame-up which can cause bodily injury or death. 4 CAUTION: The Rotisserie Burner flame may be di
Summary of the content on the page No. 17
NORMAL OPERA NORMAL OPERATION TION Using the Rotisserie WARNING: Setup the rotisserie with food before lighting Rotisserie Burner. WARNINGS: Read all instructions before using your rotisserie. Operating the Rotisserie This rotisserie is for outdoor use only. 1. Remove rotisserie shaft from grill. 2. Loosen and remove right side bearing, the counterbalance and right side spit fork. Remove motor and store in a dry place when not in use. 3. Push the rotisserie shaft through the center of t
Summary of the content on the page No. 18
HELPFUL HINTS HELPFUL HINTS Flare Ups When Using the Rotisserie Any time you cook fatty foods over an open fl ame, you can expect fl are ups. Flare ups WARNING: The rotisserie motor must be stored indoors are caused by the fl ash which occurs when the natural juices fall on the heat distribu- tion plates. Controlled fl are ups give foods their delicious outdoor fl avor and appear- when not in use. Do not leave it mounted on the grill. ance. Excessive fl are ups may occur when your grill is not lev
Summary of the content on the page No. 19
T TROUBLESHOOTING ROUBLESHOOTING PROBLEM CHECK and CURE IMPORTANT IGNITION SYSTEM Be sure that there is gas fl ow to the burners by attempting to match light your burners. If match lighting is successful, the problem lies somewhere in the ignition system and will need to be checked. MAIN GRILLING BURNERS If the main burner(s) still fails to ignite, make sure that there is gas fl owing to the burner(s) by CAUTION: Always turn the gas supply off at the tank before attempting to match light th
Summary of the content on the page No. 20
MAINTENANCE MAINTENANCE Yes, you paid a lot of money for your grill, but even an expensive grill doesn’t clean IMPORTANT and maintain itself, and you want it to look good and function properly. That’s why • Keep appliance area clear and free from combustible materials, gasoline and other this section of your manual is so important. This section gives you the information fl ammable vapors and liquids at all times. necessary to help you keep your grill looking new and working properly. Reading
