Summary of the content on the page No. 1
NATURAL GAS GRILL
OWNER'S MANUAL
3400 & 4400
GUÍA DEL PROPIETARIO DEL ASADOR DE GAS NATURAL - PG 31
- PG 47
GUIDE DE L’UTILISATEUR DU BARBECUE AU GAZ NATUREL
Assembly, Ensamblaje, Montage pg. 5
# 27010342 Customer Service: 1-800-DUCANES
WARNING: Follow all leak-check
YOU MUST READ THIS OWNER’S GUIDE
procedures carefully in this manual prior
BEFORE OPERATING YOUR GAS GRILL
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
1. Shut off ga
Summary of the content on the page No. 2
D DANGERS AND W ANGERS AND WA ARNINGS RNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNING Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ® After a period of storage, and/or non-use, the
Summary of the content on the page No. 3
W WA ARR RRA ANTY NTY, G , GA AR RA ANTÍA NTÍA,, G GA AR RA ANTIE NTIE This Limited Warranty does not cover failures or operating difficulties due to accident, abuse, ® misuse, alteration, misapplication, vandalism, improper installation, use in a commercial Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane enterprise, improper maintenance, including but not limited to damage caused by insects within Stainless Series gas grill that it will be free of defects in ma
Summary of the content on the page No. 4
PARTS LIST, LISTA DE PIEZAS, LISTE DES PI PARTS LIST, LISTA DE PIEZAS, LISTE DES PIÉ ÉC CES ES 1 2 1 1 0 1 1 1 1 1 0 1 1 1 1 1 1 0 2 2 2 2 2 2 1 1 16 16 1 1 1 1 4 4 A 24 24 1 1 B 1 1 4 4 1 1 14 14 1 0 C 28 28 1 1 1 1 0 1 1 2 C 2 2 2 4 1 1 2 4 4 www.ducane.com 3400 4400 3400 4400 3400 4400
Summary of the content on the page No. 5
PARTS LIST, LISTA DE PIEZAS, LISTE DES PI PARTS LIST, LISTA DE PIEZAS, LISTE DES PIÉ ÉC CES ES 1 1 2 2 3 4 1 1 2 2 2 2 1 1 1 1 1 1 2 2 1 1 1 1 A ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE SSEMBLY, ENSAMBLAJE, ASSEMBLAGE CAUTION: Although we take every effort to ensure that the assembly process is as easy and as safe as possible, it is inherent with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful while handling any parts during a
Summary of the content on the page No. 6
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 1 2 Front Frente Avant 6 www.ducane.com
Summary of the content on the page No. 7
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 3 4 Note: Do not fully tighten fasteners. Hand tighten only until all components are installed. Nota: No apriete los sujetadores del todo. Sólo apriete a mano hasta tanto estén instalados todos los componentes. Remarque: Ne serrez pas les fixations complètement. Serrez à lamain uniquement jusqu’à ce que la totalité des éléments soit installée. A A B B 7
Summary of the content on the page No. 8
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 3400 4400 5 5 C C C C 8 www.ducane.com
Summary of the content on the page No. 9
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 6 7 9
Summary of the content on the page No. 10
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 3400 4400 8 8 9 10 10 www.ducane.com
Summary of the content on the page No. 11
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 3400 12 11 4400 12 13 11
Summary of the content on the page No. 12
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 14 15 Note: Do not fully tighten fasteners. Hand tighten only until all components are installed. Nota: No apriete los sujetadores del todo. Sólo apriete a mano hasta tanto estén instalados todos los componentes. Remarque : Ne serrez pas les fixations complètement. Serrez à la main uniquement jusqu’à ce que la totalité des éléments soit installée. 16 17 12 www.ducane.com
Summary of the content on the page No. 13
A ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE SSEMBLY, ENSAMBLAJE, ASSEMBLAGE 18 19 Note! Fully tighten all fasteners at this time. ¡Nota! Apriete completamente todos los sujetadores ahora. Remarque! Serrez la totalité des fixations maintenant. 20 21 13
Summary of the content on the page No. 14
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 22 23 Connect all wires to the ignition box in any order. Depending on your model, one terminal will not be used and will not have a wire connection (A). Conecte todos los alambres en la caja de ignición, en cualquier orden. Dependiendo en le modelo de su asador, uno de los orificios podrá ser inactivo y no necesitara la conexión de un alambre (A). Raccordez tous les câbles au boîtier d’allumage sans vous soucier de
Summary of the content on the page No. 15
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 24 25 15
Summary of the content on the page No. 16
ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE 26 WARNING: The rotisserie motor must be stored CAUTION: Always remove the warming rack indoors when not in use. DO NOT leave it when using the rotisserie. mounted to the grill. PRECAUCIÓN: El motor deber ser almacenado OBSERVACIÓN: Siempre quite la rejilla de dentro, cuando no esté en uso. NO LO DEJE calentamiento cuando esté usando el sistema montado en la parrilla. rotativo. AVERTISSEMENT : Le moteur de rôtisseri
Summary of the content on the page No. 17
S SAFETY INFORMATION AFETY INFORMATION IMPORTANT We urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation of your new ® Ducane Gas Grill. We also advise you to keep this manual for future reference. CALIFORNIA PROPOSITION 65 WARNING: Your grill has been designed to operate using only the gas specified on the rating plate. Do not attempt WARNING: The burning of gas cooking fuel generates
Summary of the content on the page No. 18
C CONNECTION ONNECTION — — N Natural Gas Grills atural Gas Grills TYPE OF GAS Your natural gas grill is factory built to operate using natural gas only. Never attempt to 1 operate your grill on gases other than the type specified on the grill rating plates. Your grill operates at 7" of water column pressure. If replacement of the hose becomes necessary, factory specified parts are required. See your local dealer. ® 4 2 For safety and design reasons, the conversion of a Ducane grill from oper
Summary of the content on the page No. 19
C CONNECTION ONNECTION — — N Natural Gas Grills atural Gas Grills IMPORTANT Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1; Natural Gas and Propane Installation Code. IMPORTANT When connecting or replacing any gas pipe or fittings, all joints must be sealed with leak-proof sealing compound approved for use with natural and propane gases. After making connections, check all joints fo
Summary of the content on the page No. 20
NORMAL OPERATION NORMAL OPERATION BREAKING IN YOUR GRILL DANGER: Make sure that the lid is in the full open postion any time you attempt to light your grill. Failure to open the When firing your grill for the first time, it is advisable to run the Main Burner(s) on “HI” for 20 minutes with the hood down and then turn the Main Burners “OFF” . Next, run the lid could lead to delayed ignition which may result in serious Rotisserie Burner (if so equipped) on “HI” for 20 minutes with the hood
