Summary of the content on the page No. 1
ULIN_016357_30095.fm Page 1 Wednesday, February 7, 2007 12:44 PM
Use and Care Guide
®
Combo Drawer Model:
CO2175DWR
CO2175DWR
Summary of the content on the page No. 2
1 Introduction Congratulations on your purchase of a U-Line refrigeration product. A pioneer in the field for more than 40 years, U-Line Corporation is the world’s number one manufacturer of built-in, under-counter, specialty refrigeration and ice making products. U-Line dedicates 100% of its research and development to these products. The result: U-Line technology consistently leads the market with innovation, design, depth of product line and performance. U-Line products are making life mor
Summary of the content on the page No. 3
2 Table of Contents Introduction ...............................................................................................................................2 Warranty Registration .......................................................................................................2 Please Record Your Model Information ...........................................................................2 Table of Contents ...............................................................................
Summary of the content on the page No. 4
This page intentionally left blank 4 CO2175DWR
Summary of the content on the page No. 5
WARNING 3 Safety Precautions SHOCK HAZARD - Electrical Grounding Required. � PLEASE READ all instructions completely before � Never attempt to repair or perform attempting to install, operate, or service your maintenance on the unit until the electricity unit. has been disconnected. � Proper installation procedures must be followed � Never remove the round grounding prong from if this unit is being initially installed, or is moved the plug and never use a two-prong grounding to a new loc
Summary of the content on the page No. 6
� Full wrap stainless steel drawers with sculpted handles 4 Product Features distinguish this unit from heavier, “commercial” looks. � The top drawer features a stainless steel interior that is Échelon Drawer Combo corrosion-resistant and provides a sleek, professional appearance. Refrigerator, Freezer, Ice Maker � Heavy duty, full extension drawer slides permit easy Model CO2175DWR accessibility to contents in the back of drawers. A FROST FREE 5.0 cu ft (142 L) combination refrigerator/
Summary of the content on the page No. 7
Interior Lighting 5 Operation The interior drawer lights are controlled by individual switches on each drawer. As a drawer is opened, the light will go ON. The light will go OFF when the drawer is closed. The LIGHT icon (Figure 3, 5) on the control panel is used to control an additional lighting function. The blackout/ Sabbath mode (not Star K certified) will turn the interior lights and display (Figure 3, 3) off for a preset 36-hour period. ULIN_0080_A To access the blackout/Sabbath mode
Summary of the content on the page No. 8
Temperature Display Ice Maker To display the interior temperature: When the ice bucket is full, the ice making mechanism will shut off. However, the refrigeration system will continue 1. Touch and hold the WARMER icon (Figure 4, 2) for to cool and maintain the cube supply. Frost-free icemaker approximately five seconds and release when the °F units have lower ice production than manual defrost symbol in the display (Figure 4, 3) begins to flash. units. 2. The display (Figure 4, 3) will ind
Summary of the content on the page No. 9
It is normal for cubes to appear cloudy. This is caused by Normal Operating Sounds air being trapped in the water due to fast freezing. It has All models incorporate rigid foam insulated cabinets to nothing to do with the health, taste or chemical make-up of the water. It is the same air that is in every glass of provide high thermal efficiency and maximum sound reduction for its internal working components. In spite of water you drink. this technology, your model may make sounds that are
Summary of the content on the page No. 10
When adjusting the organizer, open the drawer fully, Food Storage remove the bin and all other items, and brace the drawer to prevent movement. To adjust, turn the drawer Drawers organizer knob (Figure 9, 1) counterclockwise to loosen The drawers should only be removed for servicing by a and use two hands to position as desired. Tighten knob trained and certified repair person. after adjustment is made. Do not over-tighten. Top Storage Bin Clean the drawer organizer with warm water and a m
Summary of the content on the page No. 11
Storage, Vacation, Moving Product Disposal If the unit will not be used for an extended period, or If the unit is being removed from service for disposal, otherwise stored, follow these steps completely: check and obey all Federal, State and/or Local regulations regarding the disposal and recycling of refrigeration appliances, and follow these steps completely: WARNING 1. Remove all consumable contents from the unit. Electrical Shock Hazard. Disconnect power before servicing. Before operatin
Summary of the content on the page No. 12
Maintenance 6 Cleaning and Maintenance Proper maintenance of your U-Line product will ensure efficiency, top performance and long life. The General Cleaning maintenance intervals listed are based on normal conditions. You may want to shorten the intervals if you Exterior Cleaning (As Required) have pets or other special considerations. Black Models: Defrosting � Surfaces may be cleaned with a mild detergent and warm water solution. Do not use solvent-based or Frost-Free Models abrasive cle
Summary of the content on the page No. 13
CAUTION DO NOT use any type of cleaner on the condenser unit. 4. Clean the condenser coil (Figure 11, 2) using a soft brush with a “combing” action or vacuum cleaner. Do not touch the condenser coil. 5. Position the grille to align the mounting screws with the holes in the cabinet. ULIN_0259_A 6. Secure, but do not over-tighten both grille screws. Figure 13 7. Reconnect power to the unit. 1. Remove the ice maker assembly cover (Figure 13). Ice Maker Maintenance Inlet Screen Interval - Every
Summary of the content on the page No. 14
Leveling Light Bulb Replacement NOTE: It is important that the unit is level. If unit is not To replace the light bulb in your U-Line unit: level, the ice mold may not fill evenly. 2 1 ULIN_0001_A Figure 17 1. Grasp the edges of the light housing lens (Figure 17, 1) opposite the exposed tab and gently push the lens toward the tab (Figure 17, 2). 2. Pull the edge of the lens down (Figure 17, 1) and swing it out of the light housing. ULIN_0045_A IMPOR IMPORT TAN ANT T Figure 15 ALWAYS use a gen
Summary of the content on the page No. 15
7 Service Before Calling for Service If your U-Line product appears to be malfunctioning, read through the OPERATION section of this guide to ensure that the function of all controls are clearly understood. If the malfunction persists, the TROUBLESHOOTING GUIDE in this guide will assist you in quickly identifying common problems, and provide information on possible causes and remedies. Most often, this will resolve the problem without the need to call for service. If Service is Required
Summary of the content on the page No. 16
Troubleshooting Guide DANGER ELECTROCUTION HAZARD Never attempt to repair or perform maintenance on the unit until the main electrical power has been disconnected. Troubleshooting - What to check when problems occur: PROBLEM POSSIBLE CAUSE REMEDY Unit does not operate and No electrical supply Plug unit in or check circuit breaker. electronic display is blank. No interior light. Loose or burned out bulb. Tighten or replace bulb (See MAINTENANCE; LIGHT BULB REPLACEMENT). Electronic display is b
Summary of the content on the page No. 17
PROBLEM POSSIBLE CAUSE REMEDY Noise during operation Copper water supply tubing Carefully bend tubing away from cabinet and contacting internal components components. Certain sounds are normal. Soft sounds from the fan and water/dropping sounds from the ice maker will be heard. Drawer(s) can't close. Item(s) interfering with drawer Adjust items in drawer(s). closing Unit not level Make sure unit is level. (See LEVELING, page 14.) Water is leaking out the back of the Water supply connection lea
Summary of the content on the page No. 18
Electronic Control Quick Guide All Models Task Touch Touch Display Comment Turn ON/OFF Hold 10 seconds Release when °F flashes. or °F flashes after first touch, or or Adjust set-point saved after 5 Temperature seconds of inactivity and °F Touch to change temperature Touch and release stops flashing.* View Actual For Wine Coolers, see Use Hold 5 seconds Release when °F flashes. Temperature and Care Manual. Change °F-°C Hold or Repeat to switch back. Blackout Display (and cabinet light)
Summary of the content on the page No. 19
U-Line Corporation Limited Warranty U-Line Corporation warrants each U-Line product to be free from defects in materials and workmanship for a period of one year from the date of purchase; and warrants the sealed system (consisting of the compressor, the condenser, the evaporator, the hot gas bypass valve, the dryer and the connecting tubing) in each U-Line product to be free from defects in materials and workmanship for a period of five years from the date of purchase. During the initial one
Summary of the content on the page No. 20
ULIN_016357_30095.fm Page 20 Wednesday, February 7, 2007 12:45 PM For General Inquiries: P.O. Box 245040 Milwaukee, Wisconsin 53224-9540 U.S.A. Phone (800) 779-2547 FAX (414) 354-5696 www.U-Line.com For Service and Parts Assistance: Phone (800) 779-2547 (414) 354-0300 FAX (414) 354-5696 Email: OnLineService@U-Line.com www.U-LineService.com E-mail: OnlineParts@u-line.com For more than four decades, U-Line has distinguished itself as the leader in built-in under-counter ice making, refr
