Bedienungsanleitung Trion T5200

Inhaltszusammenfassung zur Seite Nr. 1

CUSTOM PACKAGED
ELECTRONIC
AIR CLEANER
Air Boss
T-Series
Model T5200
• INSTALLATION
• OPERATION
• SERVICE
Electrostatic Precipitators for
Commercial & Industrial
Applications
101 McNeill Road • Sanford, NC 27330
(919) 775-2201 • Fax: (919) 774-8771 • (800) 884-0002
www.trioninc.com
MANUAL PART NO. 150391-001 • January 2002

Inhaltszusammenfassung zur Seite Nr. 2

TABLE OF CONTENTS Page I. Specifications.............................................................................................................................. 3 II. Preparation For Installation....................................................................................................... 3 New Unit Inspection................................................................................................................... 3 Operation................

Inhaltszusammenfassung zur Seite Nr. 3

OPERATION I. SPECIFICATIONS What is your Electronic Air Cleaner? POWER REQUIREMENTS Model Voltage HP AMPS (Max) Your air cleaner is a high efficiency contaminant T5200B 230V, 60 HZ, 3 PH. 2 6.8 collector designed to remove up to 95% of the dust, T5200B 230V, 60 HZ, 3 PH. 3 9.7 smoke, liquid aerosol and other pollutants from the air T5200C 460V, 60 HZ, 3 PH. 2 3.4 passing through it. T5200C 460V, 60 HZ, 3 PH. 3 4.9 T5200D 575V, 60 HZ, 3 PH. 2 3.2 HOW IT OPERATES T5200N 208V, 60 HZ, 3 PH. 2 6.8 No

Inhaltszusammenfassung zur Seite Nr. 4

and is accompanied with a continual snapping or arcing noise, the air cleaner requires attention and may need 2. Remove ionizer/collector cell(s), pre-filters and to be cleaned. after-filters. Cell Access Door Knobs (C): The cell access 3. Attach 600 pound test chain to the ceiling joist doorknobs are located on the door near the intake end using: of the unit. To open the cell access door, turn the knobs a. Wood joist – 1/2” –13 eye bolts counter clockwise until it releases from the cabinet. b.

Inhaltszusammenfassung zur Seite Nr. 5

IV. MAINTENANCE LIQUID AEROSOL APPLICATION INSTALLATIONS The following instructions are for use by qualified personnel. The unit is equipped with a sump, drain hole sized to accept a ½” NPT fitting. WARNING For the collection of liquid contaminant: RISK OF ELECTRIC SHOCK These serving instructions are for use by qualified 1. Install drain fitting to allow for the attachment of a personnel only. To reduce the risk of electric shock, liquid collection cup or drain hose. A drain fitting is do not p

Inhaltszusammenfassung zur Seite Nr. 6

Belt tension should be checked periodically. When a moderate force is applied to the belt midway between the pulleys, the belt should deflect approximately ½ “. CAUTION Having too much tension on the belts will shorten the belt life and place undue stress on the motor and blower bearings. V. REPLACEMENT PARTS ORDERING INFORMATION The following pages contain exploded views and Bills of Material for the Trion T Series Air Cleaners. Use these pages to determine the part numbers of the items needed.

Inhaltszusammenfassung zur Seite Nr. 7

c. Collector cell not making solid connection to access door and high voltage contact. WARNING T5200 Troubleshooting Guide Factory designed access to all electrically charged The troubleshooting chart, shown on the next page, will high voltage components contain electrical enable the user to pinpoint the cause of most problems. interlocks for the safety of operating personnel. Refer to the Ordering Information for replacement parts. Always unplug the unit while performing service Before performi

Inhaltszusammenfassung zur Seite Nr. 8

Inhaltszusammenfassung zur Seite Nr. 9

Inhaltszusammenfassung zur Seite Nr. 10

Inhaltszusammenfassung zur Seite Nr. 11

Inhaltszusammenfassung zur Seite Nr. 12

Inhaltszusammenfassung zur Seite Nr. 13

Inhaltszusammenfassung zur Seite Nr. 14

Inhaltszusammenfassung zur Seite Nr. 15