Inhaltszusammenfassung zur Seite Nr. 1
C
N
E
R
G
T
I
BAKERS
PRIDE
INSTALLATION AND OPERATING INSTRUCTIONS
IL FORNO CLASSICO OVENS
Series: FC-516, FC-616 and FC-816
INTENDED FOR OTHER THAN HOUSEHOLD USE
OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES T A ALL TIMES
RETAIN THIS MANUAL FOR FUTURE REFERENCE
IMPORTANT INSTRUCTIONS
ter Af the gas supply has been connected to your unit, it is extremely ant import to check piping for
possible leaks. o T do this, use soap and water solutions, or solutions which are expressly made for this
purpose. DO
Inhaltszusammenfassung zur Seite Nr. 2
2
Inhaltszusammenfassung zur Seite Nr. 3
INDEX I. INSTALLATION INSTRUCTIONS III.CLEANING and MAINTENANCE 1. Receiving 3 1. ainless t S teel S Surfaces 7 2. Clearances 3 2. Painted Surfaces 7 3. Set-up 3 3. Door Mechanism 7 A. Mounting Legs with Casters 3 4. Flue ent V 7 4. Pizza Decks & Optional Ceramic po T 5. Oven Interior 7 A. Three Deck allation Inst 4 A. Baking Chamber 7 B. Four Deck allation Inst 4 B. Bake Decks 7 C. Optional Ceramic op T allation Inst 4 C. Burner artment Comp 8 5. Booster Burner allation Inst 4 6. s Part Breakdo
Inhaltszusammenfassung zur Seite Nr. 4
I. INSTALLATION INSTRUCTIONS 1. RECEIVING: Read the notice on the side out carton regarding damage in transit. Damage discovered ter af opening the crate(s) / carton(s) is CONCEALED DAMAGE and the carrier must be notified immediately to send an inspector and also furnish the forms for the ’s consignee claim against the . carrier When oven arrives, it should consist of : A crate, or carton, aining cont your new oven, a carton, aining cont 4 legs with mounting hardware, and a strapped skid, aini
Inhaltszusammenfassung zur Seite Nr. 5
Sketch B Main Burner 12" FRONT VIEW (305mm) 21/4 10” 33" (57mm) (254mm) (838mm) Push-Pull Knobs 30" STD. (762mm) Oven Controls 3. -UP: SET The oven must be alled inst in a well-ventilated area. our Y oven is acked p anding st on s it back. Leave in on it’s back while acking. unp The skid may be t lef under the oven for convenience in further handling. ack Unp carefully to avoid damage to the oven. If concealed damage is found, follow the instructions ailed det in Section 1. Keep the area aroun
Inhaltszusammenfassung zur Seite Nr. 6
SketchSketch D D A. MOUNTING LEGS WITH CASTERS: Legs are shipped in a arate sep carton complete with mounting hardware and casters, (two of them with wheel brakes). NOTE : allation Inst should be made with a connector that complies with the latest edition of the andard t S for Connectors for Movable Gas Appliances ANSI Z21.69 in the USA (CAN CGA6.16 in Canada) and a quick disconnect device that complies with the latest edition of the andard t S for Quick Disconnect Devices for use with gas fu
Inhaltszusammenfassung zur Seite Nr. 7
Inhaltszusammenfassung zur Seite Nr. 8
Sketch I Wedges C. Optional Ceramic po T allation: Inst If the oven was ordered with the ceramic top option, the two top s support are already alled. inst Simply slide in the ceramic s top as per instructions . below If this option is an add-on, you must follow the instructions provided with the Ceramic op T allation Inst kit. a) Through the arched front opening, insert one of the center slabs (20 13/16 x 20 13/16 for FC616 and FC816)(17 1/2 x 17 3/4 t (lef to right) for the FC516) into the ba
Inhaltszusammenfassung zur Seite Nr. 9
d) The hot surface ignition system, all related switches, indicator light and fuse, are all connected through the 6 t f (1830 mm) power supply cord. The power supply cord must be plugged into a properly grounded three-prong acle. recept Do not cut or remove the ground prong from the plug. e) A wiring diagram may be found behind the service anel p on the t lef side of the unit and also in this manual. f) The ovens should not be alled inst on the same line with ace sp heaters, boilers or other gas
Inhaltszusammenfassung zur Seite Nr. 10
350 300 T VENT TH TH TP TP O L I P Sketch J Sketch K Pilot Feed Correct Flame 3/8” - 1/2” Gas Cock Dial Pressure Regulator Pilot Adjust Screw Thermostat 8. BURNER TION: OPERA A. MAIN BURNER: ter Af the pilot burner is ignited, when heat is desired, turn gas cock dial to the ON position and set the at thermost dial to the desired temperature. The oven burner flame should always have a blue appearance. That indicates a good mixture of gas and . air When using LP gas, the flame will have a bl
Inhaltszusammenfassung zur Seite Nr. 11
Inhaltszusammenfassung zur Seite Nr. 12
4. RECOMMENDED TING OPERA PROCEDURE It is very ant import that at the end of each ’s day operation, the gas cock dial to the Main Burners is turned back to the Pilot position and that the Booster Burner switch is flipped to the OFF (O) position, leaving only the Pilot Burner on overnight. Keep the Pizza Push/Pull slides fully open. Pre-heating: a) urn T the gas cock dial to the main burner to the ON position. oo b) Pre-heat the oven for 1 to 1 ‰ hours at 50 F (30 C) lower than your baking t
Inhaltszusammenfassung zur Seite Nr. 13
2. AINTED P ACES: SURF a) ashing W with mild soap and water solution is usually adequate to keep the side out clean. b) Apply a thin coat of oil to protect and enhance the finish. 3. DOOR MECHANISM: Every six months (more frequently if the oven is used heavily) the bottom door spring mechanism and all moving s art p must be inspected for . wear Do not apply grease to spring lever shoulder bolt, spring roller or the door rod and the door pin. They have self-lubricating s insert that will be damag
Inhaltszusammenfassung zur Seite Nr. 14
Inhaltszusammenfassung zur Seite Nr. 15
Inhaltszusammenfassung zur Seite Nr. 16
BAKERS PRIDE BAKERS PRIDE OVEN CO., INC. 30 Pine Street New Rochelle, NY 10801 (914) 576-0200 Phone (800) 431-2745 US & Canada (914) 576-0605 Fax www.bakerspride.com Web Address 16 16
