Inhaltszusammenfassung zur Seite Nr. 1
Inhaltszusammenfassung zur Seite Nr. 2
w The generator is a potential source of electrical shock if misused. Do not expose the generator to moisture, rain or snow. Do not let the generator get wet, and do not operate it with wet hands.
Inhaltszusammenfassung zur Seite Nr. 3
Thank you for purchasing a Honda generator. This manual covers operation and maintenance of the EB2200X generator. All information in this publication is based on the latest product information available at the time of approval for printing. Honda Motor Co., Ltd. reserves the right to make changes at any time without notice and without incurring any obligation. No part.of this publication may be reproduced without written permission. This manual should be considered a permanent part of th
Inhaltszusammenfassung zur Seite Nr. 4
CONTENTS CONTENTS 1. GENERATOR SAFETY ................................... 3 4 2. COMPONENT IDENTIFICATION : ............................ 6 3. PRlj-OPERATION CHECK .................................. g 4. STARTING THE ENGINE ................................... ........................................ 12 5. GENERATOR USE .................................... 14 l High altitude operation .................................. 15 6 .. STOPPING THE ENGINE ....................................
Inhaltszusammenfassung zur Seite Nr. 5
1. GENERATOR SAFETY To ensure safe operation - l Place the generator at least 1 m (3 ft) away from buildings or other equip- ment during operation. l Operate the generator on a level surface. If the generator is tilted, fuel spillage may result. l Exhaust gas contains poisonous carbon monoxide. Never run the generator in an enclosed area. Se sure to provide adequate ventilation. l Know how to stop the generator quickly and understand operation of all the controls. Never permit anyone t
Inhaltszusammenfassung zur Seite Nr. 6
2.COMPOlW3Wi- BDENTIFI AC RECEPTACLES AIR CL FILLER CAP \ OIL ALERT LAMP RECOIL / FUEL VALVE STARTER I EN’GINE SWITCH I STARTER GRIP 4
Inhaltszusammenfassung zur Seite Nr. 7
FUEL TANK FUEL SPARK PLUG MUFFLER 5
Inhaltszusammenfassung zur Seite Nr. 8
3. PRE-OPERATDON CMECK CAUTION: Be sure to check the generator on a level surfaci with the engine stopped. 1. Check the engine oil level. CAUTION: Engine oil is a maljor factor affecting engine performance and service life. Notidetergent or vegetable oils are not recommended. Use Honda 4-stroke oil, or an equivalent high detergent, premium quality motor oil certified to meet or exceed U.S. automobile manufacturers” requirements for Service Classification SG,SF/CC,CD. Motor oils classi-
Inhaltszusammenfassung zur Seite Nr. 9
2. Check the fuel level Refill I the tank if the fuel level is low. Your engine is designed to use any gasoline that has a pump octane number (v) of 86 or higher, or that has a research octane number of 91 or higher. Gasoline pumps at service station normally display the pump octane num- ber. We recommend that you use unleaded fuel because it produces fewer engine and spark plug deposits and extends the life of exhaust system components. Never use stale or contaminated gasoline or an oi
Inhaltszusammenfassung zur Seite Nr. 10
l Gasoline is extremely flammable and is explosive under certain conditions. l Refuel in a well-ventilated area with the engine stopped. Do not smoke or allow flames or sparks in the area where the engine is refueled or where gasoline is stored. l Do not overfill the fuel tank (there should be no fuel in the filler neck.) After refueling, make sure the tank cap is closed properly and secure- lY* l Be careful not to spill fuel when refueling. Spilled fuel or fuel vapor may ignite. If any
Inhaltszusammenfassung zur Seite Nr. 11
4. STARTING THE ENGINE (1) Turn off the AC circuit breaker. (2) Turn on the fuel valve. (3) Turn on the engine switch. ON
Inhaltszusammenfassung zur Seite Nr. 12
Move the choke lever to the CLOSED position. (5) Pull the starter rope lightly until resistance is felt, then pull briskly. CAUTION: Do not. allow the starter grip to snap back.’ Return it slowly by hand. NOTE: Make sure the pilot lamp comes on. If not, check the bulb filament. Move the’choke lever to the OPEN (6) position as the engine warms up.
Inhaltszusammenfassung zur Seite Nr. 13
Oil Alert System Before the oil level in the crankcase can fall below a safe limit, the Oil Alert System will automatically shut off the engine. The Oil Alert Lamp will light when the recoil starter grip is pulled. To restart, add enough recommended engine oil to bring the oil level to the upper level mark on the dipstick (See page 6), and restart the engine. ENGINE SWITCH OIL ALERT LAMP NOTE: The engine switch will remain in the ON position if the engine is stopped by the Oil Alert S
Inhaltszusammenfassung zur Seite Nr. 14
l To prevent elecrical shock from faulty appliances, the generator should be grounded. Connect a length of heavy wire between the generator’s ground terminal and an external ground source. l Connections for standby power to a building’s electrical system must be made by a qualified electrician and must comply with all applicable laws and electrical codes. Improper connections can allow electrical current from the generator to backfeed into the utility lines. Such backfeed may electrocute
Inhaltszusammenfassung zur Seite Nr. 15
AC applications 1. Start the engine and plug in the appliance; always use three-pronged plugs. 2. Switch on the AC Circuit Breaker. CAUTION: Be sure that appliances do not exceed the generator’s rated load capacity for more than 30 minutes and that they never exceed the maximum load capacity. Substantial overloading will switch off the circuit breaker. Mar- ginal overloading may not switch off the circuit breaker, but it will shorten the service life of the generator. Be sure that all ap
Inhaltszusammenfassung zur Seite Nr. 16
l Hight altitude operation At high altitude, the standard carburetor air-fuel mixture will be excessively rich. Performance will decrease, and fuel consumption will increase. High altitude performance can be improved by installing a smaller diameter main fuel jet in the carburetor and readjusting the pilot screw. If you always ,operate the generator at altitudes higher than 6,000 feet above sea level, have your authorized Honda Generator dealer perform these carburetor modifications. Eve
Inhaltszusammenfassung zur Seite Nr. 17
6. STOPPING THE ENGINE To stop the engine in an emergency, turn the engine switch OFF. (1) Turn off the AC circuit breaker. (2) Turn off the engine switch. (3) Turn off the fuel valve.
Inhaltszusammenfassung zur Seite Nr. 18
7. MAINTENANCE The purpose of the maintenance and adjustment schedule is to keep the generator in the best operating condition. Inspect or service as scheduled in the table on the next page. B Shut off the engine before performing any maintenance. If the engine must be run, make sure the area is well ventilated. The exhaust con- tains poisonous carbon monoxide gas. CAUTION: Use genuine HONDA parts or their equivalent. The use of re- placement parts which are not of equivalent quality may
Inhaltszusammenfassung zur Seite Nr. 19
Maintenance Schedule REGULAR SERVICE First Every Every Every Perform at every indi- month 3 months 6 months year cated month or oper- Daily or or or or ating hour interval, 20 Hrs. 50 Hrs. 100 Hrs. 300 Hrs. 0 Inspection Engine oil 0 0 Change 0 Inspection Air cleaner NOTE (1) : Service every 10 hours or once a day when used in dusty areas. These items should be serviced by an authorized Honda dealer, unless the (2) : owner has the proper tools and is mechanically proficient. S
Inhaltszusammenfassung zur Seite Nr. 20
Changing oil Drain the oil while the engine is still warm to assure rapid and complete draining. 1. Remove the drain plug and filler cap, and drain the oil. Retighten the plug securely. 2. Refill with the recommended oil (see page 6) and check the level. 01 L CAPACITY: 0.6 9 (0.63 USqt) OIL DRAIN PLUG CAUTION: Used motor oil may cause skin cancer if repeatedly left in contact with the skin for prolonged periods. Although this is unlikely unless you handle used oil on a daily basis, it
