Bedienungsanleitung White Rodgers 36C03

Inhaltszusammenfassung zur Seite Nr. 1

ON
ON
36C03, 36C10, 36C13 and 36D34
Combination Gas Valves
(24 Volt, 120 Volt and .750 Volt Models)
INSTALLATION INSTRUCTIONS
Operator: Save these instructions for future use!
FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE
INSTALLING OR OPERATING THIS CONTROL COULD CAUSE PERSONAL INJURY
AND/OR PROPERTY DAMAGE.
DESCRIPTION
The 36C03, 36C13 and 36D34 complete gas controls
ECO
combine into a single compact package the functions of 3-
Terminals
position gas cock, pressure regulator, 10

Inhaltszusammenfassung zur Seite Nr. 2

SPECIFICATIONS DO NOT BEGIN INSTALLATION UNTIL YOU READ THE FOLLOWING PRECAUTIONS. If you do not follow these instructions exactly, a fire or explosion may ! WARNING result, causing property damage, personal injury or loss of life. 1. Failure to turn off electric or main gas supply 3. NEVER USE FLAME OR ANY KIND OF SPARK to heating system could cause personal in- TO CHECK FOR GAS LEAKS–COULD CAUSE jury and/or property damage by shock, gas FIRE AND/OR EXPLOSION. suffocation, fire, and/or explosi

Inhaltszusammenfassung zur Seite Nr. 3

INSTALLATION (cont’d) Drop PILOT GAS CONNECTION Horizontal Install fitting into pilot gas outlet (see fig. 2), turning until finger-tight. Insert clean, deburred tubing all the way through the fitting. While holding the tubing securely, slowly tighten fitting until you feel a slight "give". Tighten the fitting an additional 1 1/2 turns. Gas Valve NOTE: Riser 3 in. Always Include minimum A Drip Leg In Piping Pilot gas PRESS Drop PILOT outlet Tubing Gas Gas Valve Supply Riser Horizontal TAP

Inhaltszusammenfassung zur Seite Nr. 4

ON INSTALLATION (cont’d) ENERGY CUT OFF (E.C.O.) PILOT GAS ADJUSTMENT CONNECTION If the pilot flame is low and does not engulf the bulb of the mercury flame sensor, the system will not energize the A five-function valve uses the two E.C.O. terminals that are main valve. If pilot gas pressure is too high, gas will sputter connected to the magnetic assembly where the thermo- past the ignition electrode, and may not ignite. High pilot couple connects to the 36C valve line interrupter. gas pressure

Inhaltszusammenfassung zur Seite Nr. 5

PILOT OFF ON PILOT LIGHTING INSTRUCTIONS AND PRECAUTIONS FOR YOUR SAFETY READ BEFORE LIGHTING If you do not follow these instructions exactly, a fire or explosion ! WARNING may result causing property damage, personal injury or loss of life. A. This appliance has a pilot that must be lighted by hand. • Immediately call you gas supplier from a neighbor's When lighting the pilot, follow these instructions exactly. phone. Follow the gas supplier's instructions. • If you cannot reach your gas suppl

Inhaltszusammenfassung zur Seite Nr. 6

NOTES 6

Inhaltszusammenfassung zur Seite Nr. 7

NOTES 7

Inhaltszusammenfassung zur Seite Nr. 8

White-Rodgers is a division of Emerson Electric Co. The Emerson logo is a trademark and a service mark of Emerson Electric Co. www.white-rodgers.com