Inhaltszusammenfassung zur Seite Nr. 1
OF OFF O OF FF
O OFF FF O OF FF F OF OFF F
OF OF FF
O OF FF F O OF FF F
30" (76.2 CM) AND 36" (91.4 CM)
CLASSIC COMMERCIAL-STYLE DUAL FUEL
CONVECTION RANGE WITH STEAM-ASSIST
INSTALLATION INSTRUCTIONS
for residential use only
Table of Contents............................................................................................................2
9758978
Inhaltszusammenfassung zur Seite Nr. 2
TABLE OF CONTENTS RANGE SAFETY .........................................................................3 INSTALLATION REQUIREMENTS ................................................4 Tools and Parts ............................................................................4 Location Requirements................................................................4 Electrical Requirements ...............................................................7 Gas Supply Requirements .....................
Inhaltszusammenfassung zur Seite Nr. 3
RANGE SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.” These words mean: You can be killed or seriously injured if you don't immediately DANG
Inhaltszusammenfassung zur Seite Nr. 4
WARNING Tip Over Hazard A child or adult can tip the range and be killed. Connect anti-tip bracket to wall behind range. Reconnect the anti-tip bracket, if the range is moved. Failure to follow these instructions can result in death or serious burns to children and adults. INSTALLATION REQUIREMENTS Backguard and attachment screws (7). NOTE: The backguard included with the range is required if Tools and Parts installed with less than 1" (2.5 cm) clearance from a Gather the required tools an
Inhaltszusammenfassung zur Seite Nr. 5
O OF FF F O OF FF F O OF FF F O OF FF F O OF FF O OF FF F O OF FF F O OF FF F Do not seal the range to the side cabinets. IMPORTANT: Some cabinet and building materials are not designed to withstand the heat produced by the oven for baking Cabinet opening dimensions that are shown must be used. and self-cleaning. Check with your builder or cabinet supplier to Given dimensions are minimum clearances. make sure that the materials used will not discolor, delaminate or The wall anti-tip b
Inhaltszusammenfassung zur Seite Nr. 6
Installation Clearances Cabinet opening dimensions shown are for 25" (64 cm) countertop depth, 24" (61 cm) base cabinet depth and 36" (91.4 cm) countertop height. 30" (76.2 cm) models 36" (91.4 cm) models O O M* M* N N L L K K A A J J I I B B H H E E D D G G F F C C A. 18" (45.7 cm) upper cabinet to countertop A. 18" (45.7 cm) upper cabinet to countertop B. 30" (76.2 cm) model: B = 22" (55.9 cm) B. 36" (91.4 cm) model: B = 28" (71.1 cm) C. Junction box to be located in this shaded area C. Junct
Inhaltszusammenfassung zur Seite Nr. 7
If the house has aluminum wiring, follow the procedure below: Electrical Requirements a) Connect the aluminum wiring to the copper wiring using If codes permit and a separate ground wire is used, it is special connectors designed and UL listed for joining recommended that a qualified electrical installer determine that copper to aluminum. Follow the electrical connector the ground path and wire gauge are in accordance with local manufacturer’s recommended procedure. codes. b) Aluminum/c
Inhaltszusammenfassung zur Seite Nr. 8
Gas Supply Line Gas Pressure Regulator Provide a gas supply line of ¾" (1.9 cm) rigid pipe to the The gas pressure regulator supplied with this range must be range location. A smaller size pipe on longer runs may result used. The inlet pressure to the regulator should be as follows for in insufficient gas supply. Pipe-joint compounds that resist proper operation: ®† the action of LP gas must be used. Do not use TEFLON Natural Gas: tape. With LP gas, piping or tubing size can be ½" (1.3 cm)
Inhaltszusammenfassung zur Seite Nr. 9
INSTALLATION INSTRUCTIONS Unpack Range Install Anti-Tip Bracket WARNING WARNING Excessive Weight Hazard Use two or more people to move and install range. Failure to do so can result in back or other injury. 1. Remove shipping materials, tape and protective film from range. Keep shipping pallet under range. Remove oven racks, grates and parts package from inside oven. Tip Over Hazard 2. Remove the 2 screws on each side of the top of the bottom A child or adult can tip the range and be killed.
Inhaltszusammenfassung zur Seite Nr. 10
4. Using the final measurement from Step 3, measure from the Electrical Connection Options floor up and mark a horizontal line on the wall where a wall If your home has: And you will be Go to Section: stud is located. connecting to: A B 4-wire direct A fused 4-Wire Cable from disconnect or Power Supply circuit breaker D box 5" C (12.7 cm) 3-wire direct A fused 3-Wire Cable from disconnect or Power Supply circuit breaker box A. Horizontal line marked from Step 4. 3¹⁄₂" (8.9 cm) B. Wall stud
Inhaltszusammenfassung zur Seite Nr. 11
Attaching the Backguard 3-Wire Cable from Power Supply 36" model shown IMPORTANT: Use the 3-wire cable from power supply where A local codes permit connecting the frame-ground conductor to the neutral (white) junction box wire. A B C G H D E F A. 3 front screws (4 rear screws required but not shown) I Attaching the Island Trim A. Cable from power supply F. 4-wire cable from range 36" model shown B. Junction box G. Black wires C. Red wires H. UL listed wire nuts D. White wire (from power suppl
Inhaltszusammenfassung zur Seite Nr. 12
D Complete Connection Adjust Flame Height 1. Open the manual shutoff valve in the gas supply line. The valve is open when the handle is parallel to the gas pipe. Adjust the height of top burner flames. The cooktop “low” burner A flame should be a steady blue flame approximately ¼" (0.64 cm) high. B A A. Closed valve B. Open valve 2. Test all connections by brushing on an approved noncorrosive leak-detection solution. Bubbles will show a B leak. Correct any leak found. 3. Remove cooktop bu
Inhaltszusammenfassung zur Seite Nr. 13
3. Press ENTER and default temperature appears in the display. 4. Press ENTER and the default cook time appears in the Complete Installation display. 1. Check that all parts are now installed. If there is an extra part, Set the cook time to 10 minutes. go back through the steps to see which step was skipped. 2. Check that range is correctly positioned in countertop cutout 5. The display will indicate “LoAd.” Open and close the oven and that the range is level. See “Level Range.” door. 3. Che
Inhaltszusammenfassung zur Seite Nr. 14
* ) ( Oven Schematic CLASSIC COMMERCIAL STYLE OVEN WITH STEAM ASSIST WIRING DIAGRAM STEAM BOARD APPLIANCE MANAGER *Blower remains off until oven reaches 190°F (88°C) and may continue running up to 45 minutes after oven has turned off. NOTE: Circuit is shown in standby/off mode with oven door closed. 14
Inhaltszusammenfassung zur Seite Nr. 15
Notes 15
Inhaltszusammenfassung zur Seite Nr. 16
9758978 7/05 © 2005. All rights reserved. ® Registered Trademark/TM Trademark of KitchenAid, U.S.A. Printed in U.S.A.
