Resumen del contenido incluido en la página 1
OUTDOOR COOKERS
WITH
GAS SHUT-OFF TECHNOLOGY
ASSEMBLY INSTRUCTIONS
AND
USE AND CARE MANUAL
MODEL/SERIAL # __________
THE INSTRUCTION MANUAL CONTAINS IMPORTANT INFORMATION
NECESSARY FOR THE PROPER ASSEMBLY AND SAFE USE OF THE APPLIANCE.
READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS BEFORE
ASSEMBLING AND USING THE APPLIANCE. FOLLOW ALL WARNINGS AND
INSTRUCTIONS WHEN USING THE APPLIANCE.
KEEP THIS MANUAL FOR FUTURE REFERENCE.
METAL FUSION, INC.
712 St. George Avenue.
Jefferson, LA 70121
For Questi
Resumen del contenido incluido en la página 2
DANGER for your safety If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your Fire Department. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN FIRE OR EXPLOSION WHICH COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. DANGER 1. Never operate this appliance unattended. 2. Never operate this appliance within 10 feet or 3.05 m of any other gas cylinder. 3. Never operate this appliance wi
Resumen del contenido incluido en la página 3
READ AND UNDERSTAND BEFORE USING THIS PRODUCT (Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove will ® be used interchangeably to refer to the King Kooker Outdoor Cooker.) 1) This is an ATTENDED appliance. Do NOT leave this appliance unattended while heating oil, grease or water, and cooking food. Monitor the appliance when hot after use [oil, grease or water above 100˚ F (38˚ C)]. Heated liquid can remain at scalding temperatures long after cooking has ended.
Resumen del contenido incluido en la página 4
12) Introduction of water or ice from any source into the oil/grease may cause overflow and severe burns from hot oil and water splatter. When frying with oil/grease, all food products MUST be completely thawed and towel dried before being immersed in the fryer. 13) Never drop food or accessories into hot cooking liquid. Lower food and accessories slowly into the cooking liquid in order to prevent splashing or overflow. When removing food from the appliance, care shall be taken to avoid burns fr
Resumen del contenido incluido en la página 5
READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE ® USING YOUR KING KOOKER PRODUCT TABLE OF CONTENTS Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Warranty . . . . . . . . . . . . . . . . . . . . . . . . .
Resumen del contenido incluido en la página 6
METAL FUSION, INC. LIMITED ONE-YEAR WARRANTY WHAT THIS WARRANTY COVERS This warranty covers all components of this outdoor cooker to be free from defects in materials and workmanship, with the exceptions stated below. HOW LONG COVERAGE LASTS This warranty runs for one year from the date of purchase. Please keep your receipt with this manual for future reference. WHAT IS NOT COVERED This warranty does not cover the following: Incidental and Consequential Damages. This warranty does not cover inci
Resumen del contenido incluido en la página 7
OWNER’S REGISTRATION ® Dear Customer, Thank you for purchasing a King Kooker®! Please take a moment to fill out your registration form and return it to us. We are always happy to hear suggestions and comments from our customers about our products. Completion of this registration allows us to contact you if the need arises. Please keep your receipt with your instruction manual. It will be necessary as a proof of purchase for us to help you if there is a problem with your cooker. Name: __________
Resumen del contenido incluido en la página 8
TAPE HERE FOLD ________________________ Place ________________________ Stamp ________________________ Here METAL FUSION, INC. 712 St. George Avenue Jefferson, LA 70121 FOLD 8
Resumen del contenido incluido en la página 9
READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE ® USING YOUR KING KOOKER PRODUCT INTRODUCTION TM Your new King Kooker® Outdoor Cooker is equipped with the SmartFryer gas shut-off system. This system helps prevent the overheating of cooking oil and fires which could result, by stopping the gas flow to the appliance. The pot contains a high temperature probe that senses when the oil temperature is too high. The system then stops gas flow to the appliance. To operate your new cooker, the pot must be
Resumen del contenido incluido en la página 10
SECTION I OUTDOOR COOKER ASSEMBLY THE USE AND CARE MANUAL MUST BE READ AND UNDERSTOOD BEFORE USING THE APPLIANCE (Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove will be ® used interchangeably to refer to the King Kooker Outdoor Cooker.) Components Before assembling, check that all cooker components are included in the shipping carton. Identify these cooker parts from the assembly drawing. Pot size may vary according to model. Check the list of accessories on
Resumen del contenido incluido en la página 11
ASSEMBLY Tools Required: Torque Wrench or Adjustable Wrench, Leak Testing Solution and Phillips Head Screwdriver 1. Read assembly instructions, and understand sequence of assembly, before commencing to assemble your cooker. 2. The casting for your cooker must be installed into the unit as instructed below before use. The assembly of the casting is required to be done with the unit in an upside down position. After assembly the unit should be turned to an upright position for use. I
Resumen del contenido incluido en la página 12
4. Place pot on cooker with wire harness assembly in line with the venturi tube. See Figure 3. FIGURE 3 5. Attach pot connector to thermocouple connector as shown in Figure 4. These must be attached for the outdoor cooker to operate. FIGURE 4 12
Resumen del contenido incluido en la página 13
SECTION II USE AND CARE (Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove will be used ® interchangeably to refer to the King Kooker Outdoor Cooker.) CONNECTION INSTRUCTIONS 1. Check that your 20 lb. LP gas cylinder is not over-filled. The maximum weight of a properly filled cylinder is approximately 38 lbs. 2. Verify that the cylinder valve has the proper connection for a Type 1 Connection. 3. Check that your hose assembly is set to not allow gas flow. If yo
Resumen del contenido incluido en la página 14
PLACEMENT INSTRUCTIONS 1. Appliance must be in open area with at least 10 feet of space on all sides. Keep the appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. 2. There must be no combustibles or roof overhead. 3. Keep 24 inches of space between the LP gas cylinder and the appliance as per Figure 1. 4. The LP gas cylinder and appliance must be located so that any wind is blowing the heat of the appliance away from the propane cylinder. T
Resumen del contenido incluido en la página 15
Resumen del contenido incluido en la página 16
(Figure 1) (Figure 2) (Figure 3) (Figure 4) (Pots Not Pictured) (Figure 5) (Figure 6) * Model May Vary from Picture NEVER PUT HANDS OR FACE DIRECTLY OVER BURNER WHILE LIGHTING. FAILURE TO FOLLOW THESE INSTRUCTIONS AND WARNINGS COULD RESULT IN FIRE, EXPLOSION OR BURN HAZARD WHICH COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. 16
Resumen del contenido incluido en la página 17
SPECIAL PRECAUTIONS FOR USING OUTDOOR COOKERS FOR DEEP FRYING 1. Always use a deep fry thermometer when frying and refer to the Instructions for Using a Thermometer, pages 14-15. 2. Never cover the pot when cooking with oil. 3. Never fill a pot beyond the maximum fill line. If the pot being used does not have a maximum fill line, follow these instructions to determine the amount of cooking oil to be used: a. Place the food product in or on the holder. b. Place the food product and holder into th
Resumen del contenido incluido en la página 18
TURNING OFF AND STORING THE COOKER AFTER USE 1. After completion of cooking turn the regulator and cylinder valve to the “OFF” position. Depress igniter button on thermoelectric valve to relieve pressure in the gas train assembly. Check to make sure there is no flame and all valves are off. Monitor the cooker until it has cooled completely. 2. Prior to removing the pot from the stand, unplug connectors attaching the wire assembly of the pot to the burner assembly. No other components of the ga
Resumen del contenido incluido en la página 19
5. Always use the gas shut-off system supplied with the appliance. Before each use of the appliance check the LP hose for evidence of abrasion, wear, cuts or leaks. Only the LP hose/regulator assembly specified by Metal Fusion, Inc. as part of the burner/gas train assembly should be used with the appliance. Visually inspect all components of the burner/gas train assembly (see Figure 1, page 10) and the pot’s wire assembly for any visible damage. Check the connectors for debris or contamination
Resumen del contenido incluido en la página 20
SECTION III COOKING SPECIALTIES DEEP FRIED TURKEY INSTRUCTIONS The following warnings and directions apply specifically to Turkey Cooker Package use. If you have ® purchased a King Kooker Turkey Package, read all the following warnings and directions before using your cooker. READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE USING THE PRODUCT 1. Use the products only outdoors, and only on a level, stable, noncombustible surface such as brick, concrete, or dirt. NOT SUITABLE are surfaces such as wood,
