ページ1に含まれる内容の要旨
PKX series
201/301/401 201H
201ST/301ST 201T/301T
ISSUE EMD-PU2117
9ZZ9990035
ページ2に含まれる内容の要旨
PKX201,301,401, 201H, PKX201T, 301T 5 5 1 2 3 2 5 201ST, 301ST 7 8 2 6 1 1 4 1 1 7 3 2 2 6 2 1 4 5 6 2 18 9 3 17 2 16 1 3 15 5W 7 3 10 14 10W 1 3 20W Single 4 grade #20 13 7 #30 8 19 #40 12 11 20 1 10W-30 Multi grade 10W-40 -20 -10 0 10 20 30 40 C Ambient temperature -4 14 32 50 68 86 104 F 23 21 22 24 8 4 4 5 1 1 PKX201T, 301T 2 5 2 6 0.6 - 0.7 mm 4 7 3 2 8 3 5 2 1 6 6 2 PKX201,301,401, 201H 1 201ST, 301ST 7 8 2 1 1 10 9 2 20 11 12 6 3 3 19 4 1 18 17 1 4 5 6 16 13 4 7 4 21 2 22 15 14 1 25 23 2
ページ3に含まれる内容の要旨
FOREWORD Thank you very much for purchasing a ROBIN PUMP. This manual covers operation and maintenance of ROBIN PUMP. All information in this publication is based on the latest product information available at the time of approval for printing. Please read this manual carefully before operating. Please take a moment to familiarize yourself with the proper operation and maintenance procedures in order to maximize the safe and efficient use of this product. Keep this owner’s manual at hand, so tha
ページ4に含まれる内容の要旨
1. SAFETY PRECAUTIONS Please make sure you review each precaution carefully. Pay special attention to statement preceded by the following words. “WARNING” indicates a strong possibility of severe personal injury or loss of life if WARNING instructions are not followed. “CAUTION” indicates a possibility of personal injury or equipment damage if instructions CAUTION are not followed. : EXHAUST PRECAUTIONS WARNING Never inhale exhaust gasses. They contain carbon monoxide, a colorless, odorless an
ページ5に含まれる内容の要旨
Do not touch the spark plug and ignition cable when starting and operating the engine. Operate the pump on a stable, level surface. If the engine is tilted, fuel spillage may result. NOTE Operating the pump at a steep incline may cause seizure due to improper lubrication even with a maximum oil level. Do not transport the pump with fuel in tank or with fuel strainer cock open. Keep the unit dry (do not operate it in rainy conditions). : PRE-OPERATION CHECKS CAUTION Carefully check fuel
ページ6に含まれる内容の要旨
SYMBOLS Read the owner's manual. Stay clear of the hot surface. Exhaust gas is poisonous. Do not operate in an unventilated area. Stop the engine before refueling. Fire, open flame and smoking prohibited. On (Run) Plus ; Positive polarity Off (Stop) Battery Engine start Engine oil (Electric start) Add oil Page 4 05.8.3, 7:11 PM ESPAÑOL FRANÇAISE ENGLISH
ページ7に含まれる内容の要旨
2. COMPONENTS (See Fig. 1 1 1 1 1) NOTE Please refer to the illustrations on the back page of the front cover or back cover for Fig. 1 1 1 1 1 to iiiii indicated in the sentence. CENTRIFUGAL PUMP (PKX201,301,401,201H) SEMI TRASH PUMP (PKX201ST,301ST) (See Fig. 1 1 1 1 1-q q q q q) !9 Strainer q Plug (drain) !0 Casing cover @0 Cushion rubber w Suction !1 Drain plug (at two places) @1 Hose coupling e Delivery !2 Stop Switch @2 Hose band r Frame !3 Recoil starter @3 Tools t Plug (priming) !4 Reco
ページ8に含まれる内容の要旨
3. PRE-OPERATION FOR STARTING (See Fig. ) 2 2 2 2 2 1. CONNECT SUCTION HOSE 4. CHECK FUEL 2 2 q q 2 2 t t (See Fig. 2 2 2-q q q) (See Fig. 2 2 2-t t t) Use a reinforced-wall or wire braided hose to prevent suction WARNING collapse. Do not refuel while smoking, near an open flame Since the pump self-priming time is directly proportional to hose length, a short hose is recommended. or other such potential fire hazards. Otherwise fire accident may occur. CAUTION Always use a strainer with the sucti
ページ9に含まれる内容の要旨
4. OPERATING YOUR PUMP 1. STARTING (See Fig. 3 3 3 3 3) 3. STOPPING (See Fig. 5 5 5 5 5) (1) Set the speed control lever at the low speed position and (1) Open the fuel cock. (See Fig.3-q) allow the engine to run at low speed for 1 or 2 minutes (2) Turn the STOP SWITCH to the position “ ” (ON). I before stopping. (See Fig.3-w) (See Fig.5-q) (2) Turn the STOP SWITCH counterclockwise to the position (3) Set the speed control lever 1/3 of the way towards the “ ” (OFF). (See Fig.5-w) high speed
ページ10に含まれる内容の要旨
2. PERIODIC INSPECTION Periodic maintenance is vital to the safe and efficient operation The maintenance schedule indicated in the following table is of your pump. based on the normal engine operation. Should the engine be operated in extremely dusty condition Check the table below for periodic maintenance intervals. or in heavier loading condition, the maintenance intervals must IT IS ALSO NECESSARY FOR THE USER OF THIS PUMP be shortened depending on the contamination of oil, clogging TO CONDUC
ページ11に含まれる内容の要旨
3. INSPECTING THE SPARK PLUG 6. CLEANING AIR CLEANER (See Fig.7 7 7 7 7-q q q q q) 7 7 t ty y (See Fig.7 7 7-t t t,y y y) (1) Clean off carbon deposits on the spark plug electrode A dirty air cleaner element will cause starting difficulty, power using a plug cleaner or wire brush. loss, engine malfunctions, and shorten engine life extremely. Always keep the air cleaner element clean. (2) Check electrode gap. The gap should be 0.6 mm to 0.7 mm. Adjust the gap, if necessary, by carefully bending
ページ12に含まれる内容の要旨
6. PREPARATIONS FOR STORAGE 8. SPARK ARRESTER (OPTIONAL) 1. WATER (See Fig.8 8 8-q q q) 8 8 q q Drain all water from the drain plug. 1. SPARK ARRESTER In a dry or wooded area, it is recommendable to use the CAUTION product with a spark arrester. Some areas require the use When retightening drain plug, be sure to clean of a spark arrester. Please check your local laws and the drain plug and the thread of casing. regulations before operating your product. Otherwise, the thread may be damaged. The
ページ13に含まれる内容の要旨
9. EASY TROUBLESHOOTING 4. WHEN ENGINE DOES NOT START : 1. PUMP DOES NOT RUN . Perform the following checks before you take the pump to Engine dose not start. your Robin dealer. If you still have trouble after completing (See 9.-4 “4. WHEN ENGINE DOES NOT START”) the checks, take the pump to your nearest Robin dealer. Sticking of impeller (Disassemble and clean.) (1) Is there a strong spark across the electrode ? Is the stop switch at position “ I ” (ON)? 2. PUMPING VOLUME IS SMALL. Remo
ページ14に含まれる内容の要旨
10. SPECIFICATIONS MODEL PKX201 PKX301 PKX401 PKX201ST PKX301ST Type Self-priming, Centrifugal pump Self-priming, Semi Trash pump Suction x Delivery 50 x 50 (2 x 2) 80 x 80 (3 x 3) 100 x 100 (4 x 4) 50 x 50 (2 x 2) 80 x 80 (3 x 3) Diameters mm(in.) Total Head m(ft) 30 (98) 31 (102) 27 (89) 30 (98) 28 (92) Maximum Delivery Volume 600 (158) 970 (256) 1350 (356) 580 (153) 930 (246) Liter(U.S.gal) / min Suction Head m(ft) 8 (26) 8 (26) 8 (26) 8 (26) 8 (26) Axle Seal Material Ceramic - carbon Silic
ページ15に含まれる内容の要旨
PKX series 201/301/401 201H 201ST/301ST 201T/301T ISSUE EMD-PU2117 9ZZ9990035
