Summary of the content on the page No. 1
GB
Instructions – Garage Door Operator Models
MotorLift 4000UK/5000UK
TM
Abbey Manor Business Centre
The Abbey, Preston Road
Yeovil, Somerset, BA20 2EN
GB For Service: 0800 317847
IRL For Service: (0044) (0) 1935 848 525
114A2062H
Summary of the content on the page No. 2
START BY READING THESE IMPORTANT SAFETY RULES These safety alert symbols mean Caution – a personal safety or property damage instruction. Read these instructions carefully. This garage door opener is designed and tested to offer reasonable safe service provided it is installed and operated in strict accordance with the following safety rules. Failure to comply with the following instructions may result in serious personal injury or property damage. Caution: If your garage has no service entrance
Summary of the content on the page No. 3
BEFORE YOU BEGIN: 8 FASTEN T-RAIL & ATTACH CHAIN SPREADER – 1. Look at the wall or ceiling above the garage door. The header Place packing material under the opener to protect the opener cover. bracket must be securely fastened to structural supports. For convenience, place a support under the cable pulley bracket end of rail. 2. Do you have a finished ceiling in your garage? If so, a support bracket and additional fastening hardware (not supplied) may be Remove the (2) washered screws (4) from
Summary of the content on the page No. 4
INSTALLATION SECTION – 11 20 15 HANG THE OPENER – The opener must be securely fastened to a structural support of the garage. Wear protective goggles when working overhead to protect your Three representative installations are shown. Yours may be eyes from injury. different. Hanging brackets (1) should be angled (Figure A) to provide rigid support. On finished ceilings, (Figure B) attach a sturdy Disengage all existing garage door locks to avoid damage to the metal bracket (not supplied
Summary of the content on the page No. 5
OPERATION OF THE LIGHTED DOOR CONTROL BUTTON 21 PROGRAM YOUR OPENER & REMOTE – Press to open or close the door. Press again to reverse the door Activate the opener only when door is in full view, free of during the closing cycle or to stop the door during opening cycle. obstruction and properly adjusted. No one should enter or leave garage while door is in motion. Do not allow children to operate push button(s) or remote(s). Do not allow children to play near the door. Your garage door opener
Summary of the content on the page No. 6
OPERATION OF YOUR OPENER 23 FORCE ADJUSTMENT – Your opener can be activated by any of the following devices: The force, as measured on the closing edge of the door, should • The Lighted Door Control Button. Hold the button down until door not exceed 150 N (15kg). If the closing force is adjusted to more starts to move. than 150 N, the Protector System must be installed. • The Outside Keylock or Keyless Entry System (if you have Do not use force adjustments to compensate for a binding or install
Summary of the content on the page No. 7
8. The garage door opens and closes by itself: HAVING A PROBLEM? 1. Opener doesn't operate from either door control or remote: Make sure remote push button is not stuck "on". • Does the opener have electric power? Plug lamp into outlet. If it doesn't light, check the fuse box or the circuit breaker. (Some outlets 9. Door stops but doesn't close completely: are controlled by a wall switch.) Review Travel Limits Adjustment. • Have you disengaged all door locks? Review installation instruction warn
Summary of the content on the page No. 8
MAINTENANCE OF YOUR OPENER SPECIFICATIONS Max. Pull Force .................800N Once a Month: Watts .................................600 • Repeat safety reverse test. Make any necessary adjustments. • Manually operate door. If it is unbalanced or binding, call for Motor professional garage door service. Type ..................................Permanent split capacitor Speed................................1500 rpm • Check to be sure door opens and closes fully. Adjust Limits and/or Force if necess
Summary of the content on the page No. 9
GB Illustrations – Garage Door Operator Models MotorLift 4000UK/5000UK TM Abbey Manor Business Centre The Abbey, Preston Road Yeovil, Somerset, BA20 2EN 114A2063E
Summary of the content on the page No. 10
1 A B C D E F 114A2063E 2
Summary of the content on the page No. 11
NOTICE 1 2 10mm, 8mm, 4,5mm, 4mm 3 11 15 16 2 13 14 1 3 4 17 19 18 21 5 20 6 12 7 22 9 24 8 25 10 26 23 114A2063E 3 2
Summary of the content on the page No. 12
4 6 4 3 2 1 5 13 14 8 10 11 7 12 9 14 114A2063E 4 NOTICE
Summary of the content on the page No. 13
5 2 6 1 2 4 3 6 2 5 3 6 2 5 6 3 6 1 4 6 2 5 4 3 3 4 1 114A2063E 5
Summary of the content on the page No. 14
7 2 1 & 3 3 2 4 1 1 8 2 3 4 5 6 3 1 8 5 9 8 7 9 114A2063E 6 5 6
Summary of the content on the page No. 15
9 1 2 1 3 2 8 5 7 8 6 5 4 9 10 11 12 114A2063E 7
Summary of the content on the page No. 16
10 1 2 3 4 13mm (1/2") 5 11 1 2 3 114A2063E 8
Summary of the content on the page No. 17
CEILING MOUNT ONLY 4 6 12 UP 1 3 2 5 4 2 5cm CEILING MOUNT ONLY 1 (2") UP 150mm A (6") 3 3 B 13 2 1 1 2 114A2063E 9 UP CEILING MOUNT ONLY UP
Summary of the content on the page No. 18
14 1 A 15 2 B 4 2 2 1 3 3 1 3 2 C 5 2 3 1 2 5 3 114A2063E 10
Summary of the content on the page No. 19
NOTICE LOCK LIGHT WHITE RED 2 1 16 2 4 1 3 2 4 1 17 4 9 3 1 2 3 6 KG KG 5 2 1 4 7 8 5 6 18 2 4 3 1 114A2063E 11 WHT 2 RED 1
Summary of the content on the page No. 20
4 5 3 2 A 20 7 1 6 6 7 11 8 4 10 13 5 3 12 9 B 4 5 3 114A2063E 12
