Summary of the content on the page No. 1
00X31-Z25-6100 EU6500is
Black DIC F101
Owner’s Manual
GENERATOR
EP2500CX
o2008 Honda Motor Co., Ltd. See page 61 for initial use
31Z15601 2eY12000.2007.12
-All Rights Reserved instructions.
Printed in Japan
Summary of the content on the page No. 2
07/11/08 17:59:00 31Z15600_001 The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. Exhaust contains poisonous carbon monoxide gas that can build up to dangerous levels in closed areas. Breathing carbon monoxide can cause unconsciousness or death. Never run the generator in a closed, or even partly closed area where people may be present. Keep this owner’s manual handy so that you can refer to it at an
Summary of the content on the page No. 3
07/11/08 17:59:07 31Z15600_002 INTRODUCTION Congratulations on your selection of a Honda generator. We are certain you will be pleased with your purchase of one of the finest generators on the market. We want to help you get the best results from your new generator and to operate it safely. This manual contains all the information on how to do that; please read it carefully. As you read this manual, you will find information preceded by a symbol. That information is intended to help you avoid da
Summary of the content on the page No. 4
07/11/08 17:59:18 31Z15600_003 A FEW WORDS ABOUT SAFETY Your safety and the safety of others are very important. And using this generator safely is an important responsibility. To help you make informed decisions about safety, we have provided operating procedures and other information on labels and in this manual. This information alerts you to potential hazards that could hurt you or others. Of course, it is not practical or possible to warn you about all the hazards associated with operating
Summary of the content on the page No. 5
07/11/08 17:59:22 31Z15600_004 CONTENTS GENERATOR SAFETY.................................................................................6 IMPORTANT SAFETY INFORMATION ...................................................6 Operator Responsibility.......................................................................6 Carbon Monoxide Hazards..................................................................6 Electric Shock Hazards .....................................................................
Summary of the content on the page No. 6
07/11/08 17:59:26 31Z15600_005 CONTENTS OPERATION ...............................................................................................18 SAFE OPERATING PRECAUTIONS ......................................................18 STARTING THE ENGINE .......................................................................20 STOPPING THE ENGINE .......................................................................22 AC OPERATION....................................................................
Summary of the content on the page No. 7
07/11/08 17:59:30 31Z15600_006 CONTENTS TAKING CARE OF UNEXPECTED PROBLEMS........................................49 ENGINE WILL NOT START....................................................................49 ENGINE LACKS POWER........................................................................50 NO POWER AT THE RECEPTACLES.....................................................51 TECHNICAL & CONSUMER INFORMATION...........................................52 TECHNICAL INFORMATION ...............
Summary of the content on the page No. 8
07/11/08 17:59:38 31Z15600_007 GENERATOR SAFETY IMPORTANT SAFETY INFORMATION Honda generators are designed for use with electrical equipment that has suitable power requirements. Other uses can result in injury to the operator or damage to the generator and other property. Most accidents can be prevented if you follow all instructions in this manual and on the generator. The most common hazards are discussed below, along with the best way to protect yourself and others. Operator Responsibility K
Summary of the content on the page No. 9
07/11/08 17:59:48 31Z15600_008 GENERATOR SAFETY Electric Shock Hazards The generator produces enough electric power to cause a serious shock or electrocution if misused. Using a generator or electrical appliance in wet conditions, such as rain or snow, or near a pool or sprinkler system, or when your hands are wet, could result in electrocution. Keep the generator dry. If the generator is stored outdoors, unprotected from the weather, check all of the electrical components on the control panel b
Summary of the content on the page No. 10
07/11/08 17:59:52 31Z15600_009 GENERATOR SAFETY Refuel With Care Gasoline is extremely flammable, and gasoline vapor can explode. Allow the engine to cool if the generator has been in operation. Refuel only outdoors in a well-ventilated area with the engine OFF. Do not overfill the fuel tank. Never smoke near gasoline, and keep other flames and sparks away. Always store gasoline in an approved container. Make sure that any spilled fuel has been wiped up before starting the engine. 8
Summary of the content on the page No. 11
07/11/08 18:00:10 31Z15600_010 GENERATOR SAFETY SAFETY LABEL LOCATIONS These labels warn you of potential hazards that can cause serious injury. Read them carefully. If a label comes off or becomes hard to read, contact your Honda servicing dealer for a replacement. 9
Summary of the content on the page No. 12
07/11/08 18:00:15 31Z15600_011 CONTROLS & FEATURES COMPONENT & CONTROL LOCATIONS Use the two illustrations on these pages to locate and identify the most frequently used controls. AC RECEPTACLES GROUND TERMINAL AC CIRCUIT BREAKER CONTROL PANEL ENGINE SWITCH 10
Summary of the content on the page No. 13
07/11/08 18:00:21 31Z15600_012 CONTROL & FEATURES FUEL VALVE LEVER CHOKE LEVER OIL FILLER CAP/ DIPSTICK AIR CLEANER SEDIMENT CUP OIL DRAIN PLUG STARTER GRIP FUEL GAUGE FUEL TANK CAP SPARK PLUG MUFFLER/SPARK ARRESTER 11
Summary of the content on the page No. 14
07/11/08 18:00:31 31Z15600_013 CONTROL & FEATURES CONTROLS Fuel Valve Lever FUEL VALVE LEVER The fuel valve lever is located O OF FF F between the fuel tank and carburetor. The fuel valve lever must be in the ON position for the engine to run. After stopping the engine, turn the fuel valve lever to the OFF O ON N position. Choke Lever CHOKE LEVER The choke lever opens and closes the choke valve in the carburetor. The CLOSED position enriches the fuel mixture for starting a cold engine. C CL LO O
Summary of the content on the page No. 15
07/11/08 18:00:44 31Z15600_014 CONTROL & FEATURES Engine Switch The engine switch controls the O OF FF F ignition system. OFF Stops the engine. O ON N ON Running position, and for starting. ENGINE SWITCH Starter Grip Pulling the starter grip operates the recoil starter to crank the engine for starting. Do not allow the starter grip to snap back against the engine. Return it gently to prevent damage to the starter. Do not let the starter rope rub against the generator body, or the rope will wea
Summary of the content on the page No. 16
07/11/08 18:00:52 31Z15600_015 CONTROL & FEATURES FEATURES Oil Alert System The Oil Alert system is designed to prevent engine damage caused by an insufficient amount of oil in the crankcase. Before the oil level in the crankcase can fall below a safe limit, the Oil Alert system will automatically stop the engine (the engine switch will remain in the ON position). If the engine stops and will not restart, check the engine oil level (see page 32 ) before troubleshooting in other areas. Ground Ter
Summary of the content on the page No. 17
07/11/08 18:00:58 31Z15600_016 CONTROL & FEATURES Fuel Gauge The fuel gauge is a mechanical device that measures the fuel level in the tank. The red indicator in the window will reference the level in relation to full or empty. To provide increased operating time, start with a full tank before beginning operation. Check the fuel level with the generator on a level surface. Always refuel with the engine OFF and cool. FUEL TANK CAP FUEL GAUGE EMPTY FULL FUEL GAUGE 15
Summary of the content on the page No. 18
07/11/08 18:01:07 31Z15600_017 BEFORE OPERATION ARE YOU READY TO GET STARTED? Your safety is your responsibility. A little time spent in preparation will significantly reduce your risk of injury. Knowledge Read and understand this manual. Know what the controls do and how to operate them. Familiarize yourself with the generator and its operation before you begin using it. Know how to quickly shut off the generator in case of an emergency. If the generator is being used to power appliances, be su
Summary of the content on the page No. 19
07/11/08 18:01:15 31Z15600_018 BEFORE OPERATION To prevent a possible fire, keep the generator at least 3 feet (1 meter) away from building walls and other equipment during operation. Do not place flammable objects close to the engine. Before beginning your preoperation checks, be sure the generator is on a level surface and the engine switch is in the OFF position. Operating this generator less than 3 feet (1 meter) from a building or other obstruction can cause overheating and damage the gener
Summary of the content on the page No. 20
07/11/08 18:01:22 31Z15600_019 OPERATION SAFE OPERATING PRECAUTIONS Before operating the generator for the first time, please review the GENERATOR SAFETY section and the chapter titled BEFORE OPERATION. For your safety, do not operate the generator in an enclosed area such as a garage. Your generator’s exhaust contains poisonous carbon monoxide gas that can collect rapidly in an enclosed area and cause illness or death. Exhaust contains poisonous carbon monoxide gas that can build up to dangerou
