Streszczenie treści zawartej na stronie nr. 1
LP Gas Grill Users Manual
Model 4280
Walk-A-Bout™ Gas
1 lb propane cylinder not included
For Outdoor Household Use Only. Not for Commercial Use.
DANGER WARNING
! !
• This instruction manual contains im-
If you smell gas:
portant information necessary for
1. Shut off gas to the appliance.
the proper assembly and safe use of
2. Extinquish any open flame.
this appliance. Failure to follow these
3. Open lid.
instructions could result in death or
4. If odor continues, keep away from
serious inju
Streszczenie treści zawartej na stronie nr. 2
2 DANGER ! CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide, an odorless toxic gas. Us- ing it in an enclosed space can kill you. Never use this appliance in an enclosed space, such as a camper, tent, car, or home. This appliance is not intended for and should never be used as a heater. WARNING ! To reduce the risk of serious injury or death from fire or explosion: • Never use alcohol, prescription or non-prescription drugs while assembling or safely
Streszczenie treści zawartej na stronie nr. 3
3 CAUTION ! To reduce the risk of a laceration hazard, wear protective gloves when handling parts that have sharp edges. Preparation for Assembly This Grill is pre-assembled. Unlock Hood Latch. (See Illustration) Remove Cooking Grid, Grease Cup, Wire Grease Cup Holder and Owner’s Manual from the grill. Make sure there are no loose parts before discarding packing materials. Packing List Owner’s Manual and Warranty Card (not pictured) Grill Body Grease Cup Wir
Streszczenie treści zawartej na stronie nr. 4
4 Set-Up Instructions Step 1 Step 2 Lay grill on its side. Place on grass or a Swing Pivot Latch away from the Leg soft surface to prevent paint damage. Crossrod to allow the legs to pivot. ! CAUTION PINCH HAZARD To reduce the risk of bodily injury from pinch hazard, keep hands and fingers away from hinges and leg pivot points. Pivot Latch Read and follow these instruc- tions to set up your grill. Leg Crossrod Step 3 Step 4 Step 5 Swing Legs away from grill
Streszczenie treści zawartej na stronie nr. 5
5 Using Gas LP Gas Cylinder DANGER ! If you see, smell, or hear the hiss of LP gas escaping from the cylinder: 1. Do not attempt to light appliance. 2. Extinguish any open flame. 3. Disconnect from fuel supply. Carbon Monoxide Hazard • This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. • Never use this appliance indoors, on recreational vehicles, or boats. WARNING ! To reduce the risk of serious injury or death from fire or explosio
Streszczenie treści zawartej na stronie nr. 6
6 NOTE: If the regulator assembly is not working properly and you need a replace- ment, contact Customer Service at 1-800-251-7558 or go to www.aussiegrills.com. Be sure to have the grill model number and
Streszczenie treści zawartej na stronie nr. 7
7 Before Using Your LP Gas Grill Installation Codes WARNING ! To reduce the risk of serious bodily injury or death from fire or explosion: • This installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54 Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2 or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192 and CSA Z240 RV Series, Recreational Vehicle Co
Streszczenie treści zawartej na stronie nr. 8
8 Lighting the Grill Using the Pulse-Spark Ignitor 1. Open the Hood. 2. Push LEFT Burner Control Knob on Control Panel in and turn 90 degrees counterclockwise to the High position. 3. Push the Igniter Button in repeatedly until the Burner is lit (Fig. 2). Listen for the click indicating spark ignition, and look to make sure the Burner is lit. 4. From the “Off” position, light the other Right hand burner. Your grill has a Crossover Ignition System that allows the Right burner to light from th
Streszczenie treści zawartej na stronie nr. 9
9 Check The Flame WARNING ! To reduce the risk of death or serious injury from an explosion or a fire: • Inspect and clean Burner/Venturi Tubes for insects or insect nests, especially after periods of storage. Spiders or small in- sects can build nests, webs, and lay eggs in the grill’s Venturi Tubes, obstructing the flow of gas to the Burner. (Fig. 6)The backed-up gas can ignite behind the Control Panel and cause a fire beneath the grill. This is known as a “flashback.” • Be sure Burners are r
Streszczenie treści zawartej na stronie nr. 10
10 Care and Maintenance Cleaning the Grill CAUTION ! To reduce risk of laceration hazard, wear protective gloves when handling parts with sharp edges. Grease Cup: Remove the Grease Cup from the Wire Holder under the grill bowl after the grill has cooled completely. Scrape away food and fat residue from the Grease Cup. Empty and wash the Grease Cup with hot soapy water and a cloth. A replacement Grease Cup can be ordered online at www.AussieGrills.com Grill Body: Do not mistake the accumulatio
Streszczenie treści zawartej na stronie nr. 11
11 How to Clean the Burners 1. Make sure the Control Knobs are turned “Off” and the grill is completely cooled. 2. Carefully remove Cooking Grid and Flavor Activators. 3. To remove each Main Burner, first remove the Crossover held in place between the burners by 2 screws. (Fig. 7) (Note the Crossover orientation during removal and replace in the same position) 4. Next, remove the Bolts and Nuts that fasten the Burner flanges to back wall. 5. Last, detach the electrode wire from the electrode on
Streszczenie treści zawartej na stronie nr. 12
12 Cooking On the Gas Grill WARNING ! To reduce the risk of serious injury or death from fire, explosion or burn hazard: • Never use charcoal or lighter fluid in your gas grill. Keep this outdoor cooking appliance clear and free from combustible materials, gasoline, and other flammable vapors and liquids. • Keep any electrical supply cord and regulator hose away from any heated surfaces. • Make sure there are no gas leaks or obstructions to the flow of combustion and ventilation air before each
Streszczenie treści zawartej na stronie nr. 13
13 Roasting (Indirect Method) WARNING ! To reduce risk of burn injury from hot air/steam trapped inside grill, open Hood carefully when roasting on grill. Food is cooked like in an oven under lower heat and/or longer cooking times. These foods require more than 25 minutes grilling time and some are so delicate that Direct Cooking would dry them out or scorch them. Use the Indirect Cooking Method to cook whole meats such as roasts, ribs, chickens, turkeys, and other large cuts of meat, as well
Streszczenie treści zawartej na stronie nr. 14
14 Troubleshooting Problem Possible Cause Solution Burners will not light using Burners not assembled correctly See re-assembly after cleaning in the ignitor “Care and Maintenance.” Not pressing igniter in enough When lighting the first (LEFT HAND) Burner, push Control for spark. Knob in and turn counterclockwise to the “High” position. Depress the Igniter Button until a loud click is heard. Repeat until the Burner lights. No spark - out of place, loose, 1. Electrode tip is bent (making too
Streszczenie treści zawartej na stronie nr. 15
15 Parts List and Illustration - Model 4280 WAB Gas Key Description Quantity 1 Cooking Grid 1 2 Flavor Activator 2 3 Burner Crossover 1 4 Stainless Steel Tube Burner 2 5 Electrode Assembly 1 6 Wire Grease Cup Holder 1 1 7 Grease Cup 1 8 Control Knob 2 9 Control Panel 1 10 Piezo Igniter 1 11 Valve/Regulator Assembly 1 2 12 Heat Shield 1 13 Hood Handle 1 If you need replacement parts, refer to the Parts Illustrations to find the exact parts you need. If you have any questions or need 3 13 help,
Streszczenie treści zawartej na stronie nr. 16
16 Limited Warranty MECO CORPORATION - LIMITED WARRANTY This product is warranted to the original consumer purchaser against defects in material and workmanship under normal outdoor household use and correct assembly (if assembled by the consumer purchaser). All parts are warranted for a period of 90 days from the date of purchase. MECO CORPORATION DOES NOT warrant in any way the propane cylinder (see label on cylinder for cylinder manufacturer’s warranty.) The LP Cylinder manufacturer is re
