Краткое содержание страницы № 1
SIDE FLAIL
ASSEMBLIES
JD 5065M / JD 5085M-105M
CAB
Current as of 06/27/2011
PARTS LISTING WITH
MOUNTING AND OPERATING
INSTRUCTIONS
Tiger Corporation
3301 N. Louise Ave.
Sioux Falls, SD 57107
1-800-843-6849
1-605-336-7900
www.tiger-mowers.com
06010007
Краткое содержание страницы № 2
TO THE OWNER / OPERATOR / DEALER All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents. BEFORE YOU START!! Read the safety messages on the implement and shown in this manual. Observe the rules of safety and use com
Краткое содержание страницы № 3
FORWARD This manual contains information about many features of the Tiger mowing and roadside maintenance equipment. Some of these include: Safety precautions, Assembly instructions, Operations, Maintenance and Parts. This manual will also assist you in the proper break-in, daily care, and troubleshooting of your new mower. We recommend that you read carefully the entire manual before operating the unit. Also, time spent in becoming fully acquainted with its performance features, adjustments
Краткое содержание страницы № 4
Краткое содержание страницы № 5
TABLE OF CONTENTS SAFETY SECTION_____________________________________ 1 ASSEMBLY / MOUNTING SECTION______________________ 2 OPERATION SECTION_________________________________ 3 MAINTENANCE SECTION______________________________ 4 PARTS SECTION______________________________________ 5 COMMON PARTS SECTION____________________________ 6 WARRANTY INFORMATION_____________________________ 7 This symbol means: CAUTION – YOUR SAFETY IS AT RISK! When you see this symbol, read and follow the associated inst
Краткое содержание страницы № 6
Краткое содержание страницы № 7
SAFETY SAFETY SECTION Side & Rear flail Safety Section 1-1
Краткое содержание страницы № 8
SAFETY General Safety Instructions and Practices A safe and careful operator is the best operator. Safety is of primary importance to the manufacturer and should be to the owner / operator. Most accidents can be avoided by being aware of your equipment, your surroundings, and observing certain precautions. The first section of this manual includes a list of Safety Messages that, if followed, will help protect the operator and bystanders from injury or death. Read and understand these Sa
Краткое содержание страницы № 9
SAFETY PELIGRO! Si no lee Ingles, pida ayuda a alguien que LEA EL si lo lea para que le traduzca las medidas INSTRUCTIVO! de seguridad. (SG-3) Never operate the Tractor or Implement until you have read and DANGER! completely understand this Manual, the Tractor Operator’s Manual, and each of the Safety Messages found in the Manual or on the Tractor and Implement. Learn how to stop the tractor engine suddenly in an emergency. Never allow inexperienced or untrained personnel to operate the Trac
Краткое содержание страницы № 10
SAFETY DANGER! Never allow children or other persons to ride on the Tractor or Implement. Falling off can result in serious injury or death. (SG-10) DANGER! Never allow children to operate or ride on the Tractor or Implement. (SG-11) WARNING! Do not mount the tractor while the tractor is moving. Mount the tractor only when the tractor and all moving parts are completely stopped. (SG-12) DANGER! Start tractor only when properly seated in the tractor seat. Star
Краткое содержание страницы № 11
SAFETY WARNING! The operator and all support personnel should wear hard hats, safety shoes, safety glasses, and proper hearing protection at all times for protection from injury including injury from items thrown by the equipment. (SG-16) CAUTION! PROLONGED EXPOSURE TO LOUD NOISE MAY CAUSE PERMA- NENT HEARING LOSS! Tractors with or without an Implement at- tached can often be noisy enough to cause permanent hearing loss. We recommend that you always wear hearing protection if t
Краткое содержание страницы № 12
SAFETY WARNING! Never attempt to lubricate, adjust, or remove material from the Implement while it is in motion or while tractor engine is running. Make sure the tractor engine is OFF before working on the Implement. (SG-20) WARNING! Periodically inspect all moving parts for wear and replace when necessary with authorized service parts. Look for loose fasteners, worn or broken parts, and leaky or loose fittings. Make sure all pins are properly secured.
Краткое содержание страницы № 13
SAFETY DANGER! NEVER use drugs or alcohol immediately before or while operating the Tractor and Implement. Drugs and alcohol will affect an operator’s alertness and coordination and therefore affect the operator’s ability to operate the equipment safely. Before operating the Tractor or Imple- ment, an operator on prescription or over-the-counter medication must consult a medical professional regarding any side effects of the medi- cation that would hinder their ability to operate the Equipme
Краткое содержание страницы № 14
SAFETY DANGER! The rotating parts of this machine have been designed and tested for rugged use. However, the blades could fail upon impact with heavy, solid objects such as metal guard rails and concrete structures. Such impact could cause the broken objects to be thrown outward at very high velocities. To reduce the possibility of property damage, serious injury, or even death, never allow the cutting blades to contact such obstacles. (SGM-4) WARNING! Extreme care should be taken when opera
Краткое содержание страницы № 15
SAFETY Flail Mowers are capable under adverse conditions of throwing objects DANGER! for great distances (100 yards or more) and causing serious injury or death. Follow safety messages carefully. STOP MOWING IF PASSERSBY ARE WITHIN 100 YARDS UN- LESS: -Front and Rear Deflectors are installed and in good, working condition; -Mower Head is running close to and parallel to the ground without exposed Blades; -Passersby are outside the existing thrown-object zone;
Краткое содержание страницы № 16
SAFETY Always disconnect the main PTO Driveline from the Tractor before DANGER! performing service on the Mower. Never work on the Mower with the tractor PTO driveline connected and running. Blades or Drivelines could turn without warning and cause immediate entanglement, injury or death. (SRM-3) Do not let the Blades turn when the Mower Deck is raised for any WARNING! reason, including clearance or for turning. Raising the Mower deck exposes the Cutting Blades which creates a potentially ser
Краткое содержание страницы № 17
SAFETY DANGER! The flail cutter shaft is designed for standard rotation (same rotation as the tractor wheels during forward travel). Never operate the cutter shaft in the reverse rotation. Operating this mower in reverse rotation may cause objects to be thrown out the front of the mower head. The rotating parts of this machine continue to rotate even after the PTO has been turned WARNING! off. The operator should remain in his seat for 60 seconds after the brake has been set, the PTO disengaged
Краткое содержание страницы № 18
SAFETY PART NO. LOCATION 21405 MOWER DECK 22839 MOWER DECK 22840 INSIDE OF CAB 24028 MOWER DECK Side & Rear flail Safety Section 1-12
Краткое содержание страницы № 19
SAFETY PART NO. LOCATION 10” x 5.5” 31522 MOWER DECK 18.25” x10” 31523 HYDRAULIC TANK 42350 MOWER DECK 33743 INSIDE OF CAB Side & Rear flail Safety Section 1-13
Краткое содержание страницы № 20
SAFETY PART NO. LOCATION 42399 MOWER DECK 42400 MOWER DECK 6T3217 MOWER DECK 6T3219 INSIDE OF CAB 6T3220 FRONT PUMP MOUNT Side & Rear flail Safety Section 1-14
