ملخص المحتوى في الصفحة رقم 1
®
M MADE IN USA ADE IN USA
®
Aussie
by Meco
Gas Grill
LP cylinder not included
®
MODEL 4280 WALK-A A-B BOUT
O OW WN NE ER R’’S S M MA AN NU UA AL L
FOR OUTDOOR HOUSEHOLD USE ONLY. NOT FOR COMMERCIAL USE.
For Customer Service, call 1-800-251-7558 or visit our web site at www.meco.net
• Failure to follow these instructions could result in fire or explosion which could cause death,
serious personal injury, or property damage.
• Read and follow instructions carefully before assembly or use
ملخص المحتوى في الصفحة رقم 2
CONTENTS I. Features That Make Your Grill Outstanding.......................2 1) Ignition Lighting the Grill............................................8 II. Assembly Instructions........................................................3 2) Manual Lighting the Grill............................................9 A) Parts List and Illustrations..............................................3 3) Check Your Flame.....................................................9 B) Setting up Your Grill..........
ملخص المحتوى في الصفحة رقم 3
CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space, such as a camper, tent, car or home. ASSEMBLY INSTRUCTIONS To reduce the risk of serious bodily injury or death: · The use of alcohol, prescription or non-prescription drugs could impair the consumer’s ability to properly assemble or safely operate this appliance. · Do not connect LP cylinder until assembly is comple
ملخص المحتوى في الصفحة رقم 4
18 20 21 19 SETTING UP YOUR GAS GRILL To reduce the risk of a cut, pinching or other bodily injury: · Wear protective gloves when handling parts that could have sharp edges. · Be careful while folding and unfolding the Grill legs. Hood Latch STEP 3) Swing Pivot Latch away from the Leg crossrod. STEP 1) Lock Hood and Bowl STEP 2) Lay the Grill on its with the Hood Latch. side in the grass or a soft area. Leg Crossrod Bottom Bowl Fixed Leg Bracket Hook STEP 5) Grasp the Fixed Leg. Push it towar
ملخص المحتوى في الصفحة رقم 5
INSTALL GREASE CUP · Do not operate the LP gas grill without the 1 lb. LP gas cylinder or a 20 lb. cylinder connected to the grill as shown in Assembly Instructions . · Maintain cylinder in upright position to provide for To reduce the risk of serious bodily injury or death: proper fuel withdrawal. · Failure to Empty the Grease Cup underneath the Bowl · Do not use an LP gas cylinder if it shows signs of after each cooking session could result in a grease fire dents, gouges, bulges, fire dam
ملخص المحتوى في الصفحة رقم 6
20 LB. LP CYLINDER ATTACH LP CYLINDER TO GAS GRILL 1 LB. LP CYLINDER To reduce the risk of serious bodily injury or death: · Always place 20 lb. cylinder away from gas grill and traffic areas to prevent tripping over the hose. · Always turn off grill and disconnect the gas cylinder before moving the gas grill. 1) Make sure the Control Knob is in the “LOCK/OFF” position. 1) Make sure the Control Knob is in the “LOCK/OFF” position. 2) Remove the Cylinder Protective Cap from the LP cylinde
ملخص المحتوى في الصفحة رقم 7
PERFORMING A LEAK TEST OPERATING AND MAINTAINING YOUR GAS GRILL To reduce the risk of serious bodily injury or death: BEFORE USING YOUR LP GAS GRILL · Always perform a leak test before each use. · Never use a match or open flame to test for gas leaks. USING GAS · Perform a leak test in a well ventilated area. · Do not perform a leak test on a grill while it is hot or in use. · Do not use the LP gas grill if you detect a gas leak CARBON MONOXIDE HAZARD that cannot be corrected by using the lea
ملخص المحتوى في الصفحة رقم 8
1) Attach LP cylinder. Open the top Hood vent, then open 5a) If using a 20 lb. cylinder, turn cylinder handle the Hood all the way. counterclockwise to “On”. 2) Important: Make sure grill control knob is turned “Off” first. 3) If using a 20 lb. LP Cylinder, turn handle counterclockwise to “ON”. 4) Push in Control Knob and turn counter clockwise to the Check for leaks around “High” position. Cylinder Coupling Nut 5b) Check for leaks around Adapter Hose to Regulator Connection. 5) Push Igni
ملخص المحتوى في الصفحة رقم 9
MANUAL LIGHTING THE GRILL OPERATING THE LP GAS GRILL To reduce the risk of a serious burn injury when lighting To reduce the risk of serious bodily injury or death: the grill manually: · Never use charcoal in your LP gas grill. Do not use · Always light the burner with a long match holder. aerosols or store flammable liquids or materials near · Keeps hands and fingers away from the burners. this gas grill. 1) Attach LP cylinder. Open the top Hood vent, then open · Check the LP gas grill for
ملخص المحتوى في الصفحة رقم 10
COOKING ON YOUR GRILL END OF COOKING SESSION To reduce the risk of burns, overheating or a serious To reduce the risk of serious bodily injury or death: hazard: · Always turn “OFF” the Regulator Knob and remove the · Do not close the the Hood or vent while preheating. LP Cylinder when not in use. Damage or severe · Do not preheat more than the 8 minutes on the “High” impact may loosen the assembly and cause gas to position. leak outside the burner area. · Use barbecue mitts when handling
ملخص المحتوى في الصفحة رقم 11
Note: Before Reassembly of Burners you may want to fully CLEANING THE BURNERS clean the grill. See Cleaning the Grill previous page. If grill is to be stored, coat Burners lightly with cooking oil and wrap in a protective cover to keep insects out. To reduce the risk of fire beneath the grill: · Inspect and clean clogged burner/venturi tubes for 5) Re-install the Burners. Note: Make sure the Manifold insects and insect nests. nozzles protrude inside the Burner Venturi tubes. · Make sure LP
ملخص المحتوى في الصفحة رقم 12
1) Wrap aluminum foil around the Burners to prevent insects from entering the burner holes. Before next use, remove aluminum foil from Burners. 2) To maintain the condition and extend the life of your grill, cover the unit when stored outside for any length of time, especially during the winter months. 3) Periodically check and tighten all nuts, bolts, and screws. Make sure all electrode and ground wires are not loose. 4) Make sure the Grill works mechanically and that the Grill Hood l
ملخص المحتوى في الصفحة رقم 13
IMPORTANT NOTICE (Only if using a 20 lb. LP Cylinder and an adapter hose) The Gas Grill is can be setup to operate with a LP Gas Cylinder equipped with an OPD (Overfilling Prevention Device). This is a secondary device to prevent the overfilling of your LP Gas cylinder. The proper methods for the filling of your LP Gas cylinder are by weight or volume, as described in NFPA 58. Please make sure your filling station fills your LP Gas cylinder by weight or volume. Ask your filling stat
ملخص المحتوى في الصفحة رقم 14
TROUBLESHOOTING Problem: Possible Cause: Solution: Burner will not Not pausing long enough before When lighting the Burner, push-in and turn Regulator knob clicking the Ignitor Button counter-clockwise to the high position. Push in Ignitor button light with the several times so that it clicks each time. Ignitor or match No spark The spacing between electrode and Burner ports should be approximately 3/16”. Make sure wire connections are secure and burner is attached securely to brackets. LP
ملخص المحتوى في الصفحة رقم 15
WARRANTY MECO CORPORATION LIMITED WARRANTY This product is warranted to the original consumer purchaser against defects in material and workman- ship under normal outdoor household use and correct assembly (if assembled by the consumer-purchas- er). All parts are warranted for a period of (90) days from the date of purchase. Meco Corporation DOES NOT warrant in any way the propane cylinder (see label on cylinder for cylinder manufacturer’s warranty.) The LP cylinder manufacturer is responsible
ملخص المحتوى في الصفحة رقم 16
® ® Aussie by Meco P/N 03.6097.00 REL. 3/06 16
